Monitoring System
Show/hide table
注意 |
---|
当监测器发出警报时,应立即检查监测器,按监测器的指示作必要的工作或保养。 监测指示灯并不能保证该机器是处于良好状况。 不要使用监测面板作为唯一的检验方式。 必须定期执行机器的保养和检验。 参阅⟪操作和保养手册⟫的“保养部分”。 |
该泵配备有泵电子监控系统 (PEMS)。
该系统旨在监控泵的运行情况。 并向操作员提供警告以延长动力端和液力端的使用寿命。
标配 PEM 包括下列项:
- 泵转速感应
- 机油压力监控
- 机油温度监控
- 吸油压力监控
- 排放压力监控
- 振动监控
监控之前提到的输入,使系统确定缩短部件使用寿命的时间。 泵的运转可导致部件磨损。 系统还可以帮助确定要求对泵内部部件进行保养的时间。
下图描述了 Black Horse 油井增产泵。
Show/hide table
图 1 | g06143153 |
油井增产泵右侧视图 |
先前的图示描述了用于监控泵的系统位置。
Show/hide table
图 2 | g06143399 |
油井增产泵左侧视图 |
Caterpillar Information System:
C13, C15, and C18 Tier 4 Final Engines Nitrogen Oxide Sensor
A New Prelube Pump Is Now Used on Certain 3500 Engines {1319} A New Prelube Pump Is Now Used on Certain 3500 Engines {1319}
G3500H Generator Set Engine Sensor Calibration Required - Test
C7.1 Marine Engine Valve Mechanism Cover - Remove and Install
Marine Engine and Genset Control Panel IIIB General Information
Filter Covers and Housings are Difficult to Remove on Certain Large off-Highway Trucks {3067, 5068} Filter Covers and Housings are Difficult to Remove on Certain Large off-Highway Trucks {3067, 5068}
C175 Oil&Gas Offshore Engine Air Inlet and Exhaust System Operation
C175 Oil&Gas Offshore Engine Sensor (Data Link Type) - Test
3512C Engines for 785C Off-Highway Trucks with Dynamic Gas Blending Sensor Calibration Required - Test - In Cylinder Pressure Sensor
Improved Fan Drive Group Bolts are Now Used on Certain 784 and 785 Off-Highway Trucks {1359} Improved Fan Drive Group Bolts are Now Used on Certain 784 and 785 Off-Highway Trucks {1359}
C175 Tier 4 Final Engines for Off-Highway Trucks Backflow Valve - Test
C175 Oil&Gas Offshore Engine Cooling System Operation
New Engine Software in Now Used on Certain Commercial 3500 Series Engines {1920} New Engine Software in Now Used on Certain Commercial 3500 Series Engines {1920}
C7.1 Marine Engine Cylinder Head - Remove
C7.1 Engines and Generator Sets Aftertreatment Cooling Fan - Test
C7.1 Marine Engine Cylinder Head - Install
G3500H 50Hz Generator Sets Sensors and Electrical Components
G3500H Generator Set Engine Exhaust Temperature - Test
C7.1 Engines and Generator Sets Aftertreatment Identification Module - Test
A New Bearing Cage Assembly is Now Used in the Planetary Group on Certain Wheel Tractor-Scrapers and Off-Highway Trucks {3030, 3160} A New Bearing Cage Assembly is Now Used in the Planetary Group on Certain Wheel Tractor-Scrapers and Off-Highway Trucks {3030, 3160}
C7.1 Engines and Generator Sets ARD Fuel Supply - Test
The Large Painted on Arrow Used on Turbine Inlet Bellows on Certain C175 Engines Is Temporarily Being Removed {1059} The Large Painted on Arrow Used on Turbine Inlet Bellows on Certain C175 Engines Is Temporarily Being Removed {1059}
C7.1 Marine Engine Piston Cooling Jets - Remove and Install
C7.1 Engines and Generator Sets ARD Ignition - Test