Electrical System
充电器正在工作时，切勿从蓄电池上断开任何充电器电路或蓄电池电路电缆。 否则，由某些蓄电池产生的易燃气体可能被火花点燃。
为便于防止因点燃某些蓄电池产生的可燃气体而生成的火花，负极 "-" 电缆应该最后从外接电源连接到主接地位置。
每天检查电线有无松动或擦破。 在发动机起动之前，拧紧所有松动的电气连接。 发动机起动之前，要修理好所有擦破的电线。 请参阅操作和保养手册以了解具体的起动说明。
接地方法
Show/hide table
 | |
| 图 1 | g02407417 |
典型示例 (1) 蓄电池接地 (2) 主接地位置 (3) 起动马达接地 (4) 缸体接地 | |
Show/hide table
 | |
| 图 2 | g02407418 |
典型示例 (5) 蓄电池接地 (6) 缸体接地 | |
为获得发动机的最佳性能和可靠性，必要将发动机电气系统正确接地。 接地不当会造成电路失控和不可靠。
失控的电路会对曲轴的轴承轴颈表面和铝质部件造成损坏。
未安装发动机至机架接地带的发动机可能因电气放电而损坏。
为确保发动机和发动机电气系统工作正常，必须使用与蓄电池直接相连的发动机到机架的接地带。 这种直接相连可通过将发动机接地线直接连接到机架实现。
接地连接应当紧凑、无腐蚀。 发动机交流发电机必须通过一根足以承受其满载充电电流的导线接地到蓄电池的负极 "-" 端子。
发动机的电源连接和接地连接都应从蓄电池的隔离器引出。
Caterpillar Information System:
Guidelines for Routing and Installing Wire Harness Assemblies {1408, 7553} Guidelines for Routing and Installing Wire Harness Assemblies {1408, 7553}
C4.4 Industrial Engine High Pressure Fuel Lines
C27 and C32 Engines for Caterpillar Built Machines Exhaust Temperature Is High
C13, C15, and C18 Tier 4 Final Engines Exhaust Lines (DPF Inlet)
C13, C15, and C18 Tier 4 Final Engines Exhaust Manifold
Roller Service Evaluation Checklist {4154, 4180, 4181, 7561} Roller Service Evaluation Checklist {4154, 4180, 4181, 7561}
C27 and C32 Tier 4 Engines Water Pump - Test
C13, C15, and C18 Tier 4 Final Engines Crankshaft
C9.3 Tier 4 Interim Engines Configuration Parameters
349F and 352F Excavators Machine System Cylinders (Boom, Stick and Bucket)
C27 and C32 Generator Set Engines Fuel Transfer Pump
Hydraulic Excavator Roller Disassembly and Assembly Procedures {0729, 0768, 4154, 4180, 4181} Hydraulic Excavator Roller Disassembly and Assembly Procedures {0729, 0768, 4154, 4180, 4181}
C6.6 Marine Generator Set ECM Memory - Test
C15 and C18 Engines for Caterpillar Built Machines Speed Control - Test
C175-16 PETROLEUM ENGINES Engine Oil and Water Pump Drive - Disassemble
C175-16 PETROLEUM ENGINES Engine Oil and Water Pump Drive - Assemble
C27 and C32 Engines for Caterpillar Built Machines Oil Contains Coolant
C6.6 Generator Set Engine Pressure Sensor Open or Short Circuit - Test
2010/01/28 A New Seal Kit Is Used on G3500C and G3500E Aftercoolers {1063, 7555}
C27 and C32 Engines for Caterpillar Built Machines Power Is Intermittently Low or Power Cutout Is Intermittent
345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Cab - Remove
345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Cab - Install
C27 and C32 Engines for Caterpillar Built Machines Valve Lash Is Excessive
C27 Generator Set Engines General Information