Water Pump - Test
Show/hide table
所需工具     | ||
零件号     | 零件名称     | 数量     |
6V-7775     | 气压表     | 1     |
8J-7844     | 转接接头     | 1     |
3K-0360     | O 形密封圈     | 1     |
5P-2725     | 探头密封转接接头     | 1     |
164-2192     | 压力探头     | 1     |
5P-4487     | 接头     | 1     |
5P-2720     | 探头适配器总成     | 1     |
Show/hide table
图 1 | g01996279 |
G3304B 和 G3306B 发动机的测压口 (1) 水泵出口处的测压口 (2) 水泵入口处的测压口 |
Show/hide table
图 2 | g02371797 |
CG137-8 和 CG137-12 发动机的测压口 (1) 水泵出口处的测压口 (2) 水泵入口处的测压口 |
Show/hide table
接触正在运转的发动机会因热零件而导致灼伤或因旋转零件而导致伤害。 在旋转的发动机上工作时,避免接触热零件或旋转零件。 |
水泵的进口压力和出口压力之间的压力升高是不同的。 压力升高是水泵状况的指示器。 使用端口 (1) 测量水泵出口压力。 使用端口 (2) 测量水泵进口压力。
压力升高等于出口压力减去进口压力。 以下情况下,压力升高必须保持最小值 50 kPa (7.5 psi):
- 发动机正常运转温度
- 1800 rpm 发动机转速
- 发动机全负载
Caterpillar Information System:
C32 Marine Engine Engine Oil Level - Check
797F and 797F XQ Off-Highway Trucks Cooling System Relief Valve - Clean
797F and 797F XQ Off-Highway Trucks Cooling System Pressure Cap - Clean/Replace
CX31-P600 Petroleum Transmission Transmission Covers - Side PTO
345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine System Travel Motor Lines
G3500B Engines Air Lines
797F and 797F XQ Off-Highway Trucks Cooling System Coolant Level - Check
797F and 797F XQ Off-Highway Trucks Cooling System Coolant Extender (ELC) - Add
3500 Industrial Engines Electric Starting Motor
797F and 797F XQ Off-Highway Trucks Cooling System Coolant (ELC) - Change
797 Off-Highway Truck Engine Crankcase Breather - Clean
Specifications for the Inspection of Trunnions for Series 3500 Family of Engines {1154} Specifications for the Inspection of Trunnions for Series 3500 Family of Engines {1154}
CX35-P800 Petroleum Transmission and CX35-P800-C18I and CX35-P800-C27I Petroleum Power Train Packages Pump Drive - PTO
C175-16 PETROLEUM ENGINES Turbocharger - Remove
CX35-P800 Petroleum Transmission and CX35-P800-C18I and CX35-P800-C27I Petroleum Power Train Packages Transmission Hydraulic Control
797F and 797F XQ Off-Highway Trucks Brake Accumulator - Check
CX31-P600 Petroleum Transmission Liquid Level Sensor (Transmission Oil)
793F Off-Highway Truck Machine Systems Valve (Suspension Cylinder Charging) - Remove and Install - Rear Suspension Cylinder
CX35-P800 Petroleum Transmission and CX35-P800-C18I and CX35-P800-C27I Petroleum Power Train Packages General Information
784C and 785C Off-Highway Truck/Tractors Use of Wheel Chocks
CX35-P800 Petroleum Transmission and CX35-P800-C18I and CX35-P800-C27I Petroleum Power Train Packages Power Train Electronic Control Module (Electronic Clutch Pressure Control)
793F Off-Highway Truck Machine Systems Accelerator Control - Remove and Install
CX35-P800 Petroleum Transmission and CX35-P800-C18I and CX35-P800-C27I Petroleum Power Train Packages Transmission Control
CX31-P600 Petroleum Transmission Oil Level Gauge - Dipstick