Problems with Rough Idle on Certain C15 Truck Engines{1901, 1920}
- Engine:
- C15 (S/N: SDP1-UP)
Introduction
The problem that is identified below does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.
Problem
Some engines that are listed above experience rough idle at approximately 500 rpm and no throttle response.
Solution
If the engine is experiencing rough idle at approximately 500 rpm and no throttle response, flash the Engine Control Module (ECM) with 343-XXXX or newer software.
Caterpillar Information System:
2009/04/06 Improved Procedure for Verifying the Operation of the Battery Disconnect System. {1411}
C4.4 Industrial Engine Engine Lifting Bracket
C4.4 Industrial Engine Flywheel
C6.6 Industrial Engine Flywheel Housing
C4.4 Industrial Engine Gear Group (Front)
C7.1 Industrial Engine Water Pump
C7.1 Engines for Caterpillar Built Machines Piston Cooling Jet
C6.6 Industrial Engine Connecting Rod
C6.6 Industrial Engine Connecting Rod Bearing Journal
C6.6 Industrial Engine Crankshaft Seals
C7.1 Engines for Caterpillar Built Machines Cylinder Block
C6.6 Industrial Engine Water Temperature Regulator and Housing
C6.6 Industrial Engine Alternator
C15 and C18 Engines for Caterpillar Built Machines Coolant Temperature Sensor
C6.6 Industrial Engine Engine Oil Pressure Sensor
C6.6 Industrial Engine Inlet Manifold Temperature Sensor
G3500B Engines Fuel Lines
C15 and C18 Industrial Engines Water Pump - Remove and Install
2009/04/01 Cleaning a Plugged Diesel Particulate Filter (DPF) {108F}
C18 Generator Set Emissions Certification Film
2009/03/23 New Water Lines Groups Are Used for Venting of the Separate Circuit Aftercooler (SCAC) {1353, 1380}
C13 Engines for Caterpillar Built Machines Fuel Filter Base - Remove and Install
G3500B Engines Air Lines
G3500B Engines Air Lines