Alternator Will Not Charge - Charging Problem
注: 这并非电子系统故障。
- 交流发电机传动带
- 充电电路
- 调节器
- 交流发电机
- 检查交流发动机传动带的状况。 如果交流发电机传动带磨损或损坏，则更换传动带。 请参阅拆解和组装, "交流发电机 - 拆解"和 拆解和组装, "交流发电机 - 组装"。
检查交流发电机传动皮带的张紧度。 如果张力不正确，调整皮带张力。 请参阅拆解和组装, "V 形皮带 - 拆卸和安装"。
检查蓄电池电缆、配线和充电电路中的连接。 清洁并紧固所有连接。 更换所有存在故障的零件。
确认交流发电机或电压调节器工作正常。 请参阅系统操作、 测试和调整交流发电机, " - 测试"。 交流发电机不是可维修部件。 如果交流发电机不能正常工作，必须更换交流发电机。
Caterpillar Information System:
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Alternator Noise - Noisy Operation
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines System Configuration Parameters
TA22-4WD Agricultural Transmission Relief Valve (Transmission Lubrication)
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Flash Programming
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Factory Passwords
2006/11/20 Prevent Freezing of the Cooling System During Shipping and Storage {1063}
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Engine Wiring Information
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Sensors and Electrical Connectors
C13 and C15 On-highway Engines Component Location
G3516C, G3516E, and G3512E Generator Set Engines Integrated Temperature Sensing Module - Test
G3516C, G3516E, and G3512E Generator Set Engines Indicator Lamp - Test
G3516C, G3516E, and G3512E Generator Set Engines Ignition Secondary - Test
2006/12/25 New Software is Used {1902, 7620}
C13 and C15 On-highway Engines Oil Contains Coolant
G3516C, G3516E, and G3512E Generator Set Engines ECM - Replace
G3516C, G3516E, and G3512E Generator Set Engines Generator Output Power Sensor - Set
G3516C, G3516E, and G3512E Generator Set Engines Timing - Calibrate
3500C Marine Propulsion Engines Sensor Signal (Analog, Active) - Test
C13 and C15 On-highway Engines Variable Valve Actuator Response - Test
C13 and C15 On-highway Engines Variable Valve Actuator Oil Pressure - Test
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Can Not Reach Top Engine RPM
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Coolant in Engine Oil
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Coolant Temperature Is Too High
Caterpillar Logic Control Governor One (LCG1) and Caterpillar Logic Control Governor Two (LCG2){1251, 1264, 1908, 7620} Caterpillar Logic Control Governor One (LCG1) and Caterpillar Logic Control Governor Two (LCG2){1251, 1264, 1908, 7620}