Alternator Mounting Group - Remove and Install
开始:
- 拆下交流发电机。 请参阅拆解和组装, "交流发电机 - 拆卸和安装"。
Show/hide table
| 注意 |
|---|
|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 拆下螺栓 (2)，然后拆下交流发电机支架 (1)。
- 拆下螺栓 (3)。 将皮带轮 (4)从附件驱动装置上拆下。
- 将唇形密封件 (5)和衬套 (6)从皮带轮 (4)上拆下。
Show/hide table
| |
| 图 1 | g01246426 |
Show/hide table
| 所需工具 | |||
| 工具 | 零件号 | 零件描述 | 数量 |
| A | 1P-0520 | 起子总成 | 1 |
Show/hide table
| 注意 |
|---|
|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 用工具 (A)将衬套 (6)安装在皮带轮 (4)上。
- 使用工具 (A) 安装唇型密封 (5)。 在唇形密封上涂抹清洁的发动机机油。 将皮带轮置于附件驱动装置上，然后安装螺栓 (3)。
- 将交流发电机支架 (1) 放置到位，然后安装螺栓 (2)。
Show/hide table
|
| |
| 图 2 | g01246426 |
结束:
- 安装交流发电机。 请参阅拆解和组装, "交流发电机 - 拆卸和安装"。
Caterpillar Information System:
3508C, 3512C and 3516C Marine Engines Alternator - Remove and Install
C9 Industrial Engines Fuel Filter Base
C7 and C9 On-Highway Engines Emissions Parameters
TH31-C9I, TH31-C9P, TH31-C9T, TH35-C11I, TH35-C13I, TH35-C13T, TH35-C15I and TH35-C15T Petroleum Power Train Packages and TH31-E61 and TH35-E81 Petroleum Transmissions Power Train Electronic Control System Service Tools
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System General Information
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Diagnostic Capabilities
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Connector Locations
C9 Industrial Engines Fuel Filter Base
C-9 Industrial Engine Fuel Filter Base
Inspection and Salvage of Hydraulic Cylinder Components {7562} Inspection and Salvage of Hydraulic Cylinder Components {7562}
3516 Generator Set Engine Governor - Woodward 2301A Speed Control
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Wiring Harness (Short Circuit) - Test
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Transmission, SPN 158 - FMI 2
C18 Marine Auxiliary and Marine Generator Set Engines Engine Oil Filter Base
C27 and C32 Engines for Caterpillar Built Machines Fuel Transfer Pump
G3500 A3 Engines Ignition System
C175 Generator Sets Fuel System Secondary Filter - Replace
Update of Parameters for Throttle Inputs During Commissioning Procedure{1901, 4490} Update of Parameters for Throttle Inputs During Commissioning Procedure{1901, 4490}
C18 Marine and Marine Generator Set Engines Engine Oil Filter Base
2006/03/13 The Heater and Air Conditioner Fan Motor has been Enhanced to Improve Motor Life {5927, 7304, 7320}
G3500 A3 Engines Location of Components
G3500 A3 Engines Carburetor
2006/02/20 Installation of a Spring in the Oil Filter Bypass Valve on Certain Applications {1306}
G3500 A3 Engines Air/Fuel Ratio Control - Oxygen Feedback