C9 Engine for the 816F Series 2 Landfill Compactor, the 815F Series 2 Soil Compactor, and the 814F Series 2 Wheel Dozer Caterpillar


Fuel Pressure Is Low

Usage:

814F II BXG
Use this procedure in order to troubleshoot a low fuel pressure, or use this procedure if the following event code is active.

Table 1
Event Code    
Description     Default Conditions which Generate this Code     System Response    
E198(1) Low Fuel Pressure     The fuel pressure drops below
175 kPa (25 psi) for ten seconds.    
The code is logged.    
E198(2) Low Fuel Pressure     The fuel pressure drops below
150 kPa (22 psi) for 15 seconds.    
The code is logged.
The engine is derated.    

Probable Causes

  • Fuel level

  • Fuel tank cap

  • Diagnostic codes and event codes

  • Fuel pressure sensors

  • Fuel pressure regulating valve

  • Fuel priming pump

  • Fuel transfer pump

Recommended Actions

Fuel Level

Visually inspect the fuel level in the fuel tank. Ensure that the fuel tank contains enough fuel in order to operate the engine.

Fuel Tank Cap

Remove the fuel tank cap from the fuel tank. Check the vent port that is in the cap for debris. Clear any restrictions with compressed air.

Note: Do not allow debris to enter the fuel tank while you clean the cap. Damage to the fuel system will occur.

Diagnostic Codes and Event Codes

Connect Caterpillar Electronic Technician (ET) to the service tool connector. Check for active diagnostic codes and event codes.

Look for active diagnostic codes that are related to the low pressure fuel system. Use the appropriate circuit test to troubleshoot any active codes before continuing.

Fuel Pressure Sensors

Start the engine. Run the engine at low idle. Use Cat ET to monitor the fuel pressure for the engine.

Check the value of the parameter while the engine is at low idle. Ensure that the value of the parameter is reasonable.

Increase the engine speed while you monitor the parameter. Ensure that the value of the parameter increase with engine speed. Ensure that the value of the sensor remains reasonable as the pressure is increased.

If a problem with the sensor is suspected, replace the suspect sensor.

Fuel Pressure Regulating Valve

A fuel pressure regulating valve that is stuck in the open position may cause low fuel pressure. If a problem with the valve is suspected, the problem is probably caused by contamination or debris lodged between the valve and the valve seat. Remove the valve assembly from the fuel filter base. Inspect the valve assembly for contamination or debris. Clean any contamination or debris that may keep the regulating valve open. If debris is present, find the source of the contamination.

If the fuel pressure regulating valve is the suspected cause of the low fuel pressure, replace the valve assembly.

Fuel Priming Pump

The electric fuel priming pump is used to prime the low pressure fuel system. Ensure that the electric fuel priming pump is achieving the correct pressure. Refer to Systems Operation/Testing and Adjusting for additional information that is related to testing the low pressure fuel system.

Fuel Transfer Pump

The fuel transfer pump may not be pumping an adequate volume of fuel in order to maintain the correct pressure in the low pressure fuel system. If the correct pressure in the low pressure fuel system is not maintained during start-up the engine will start, but the engine will not continue running.

Use Cat ET to monitor the "Fuel Pressure" status parameter during engine starting.

If the other components in the fuel system are operating within specifications, and the fuel pressure decreases after starting the engine, replace the fuel transfer pump.

Caterpillar Information System:

C9 Engine for the 816F Series 2 Landfill Compactor, the 815F Series 2 Soil Compactor, and the 814F Series 2 Wheel Dozer Event Code List
PL61 Pipelayer and D6K Track-Type Tractor Using Caterpillar Electronic Technician to Determine Diagnostic Codes
D6T Track-Type Tractor Hydraulic System Control Valve (Ripper)
IT38H Integrated Toolcarrier and 938H Wheel Loader Engine Supplement Radiator - Remove and Install
IT38H Integrated Toolcarrier and 938H Wheel Loader Engine Supplement Aftercooler - Remove and Install
C4.4 and C6.6 Industrial Engines and Engines for Caterpillar Built Machines Can Not Reach Top Engine RPM
816F Series 2 Landfill Compactor, 815F Series 2 Soil Compactor and 814F Series 2 Wheel Dozer MID 081 - CID 1757 - FMI 04
816F Series 2 Landfill Compactor, 815F Series 2 Soil Compactor and 814F Series 2 Wheel Dozer MID 081 - CID 1757 - FMI 03
816F Series 2 Landfill Compactor, 815F Series 2 Soil Compactor and 814F Series 2 Wheel Dozer MID 081 - CID 1711 - FMI 04
C4.4 and C6.6 Engines for Caterpillar Built Machines System Configuration Parameters
3306C Engines for Caterpillar Built Machines Fan Drive
AD55B Underground Articulated Truck Power Train Electronic Control System Backup Alarm Always Off
3412E Engine for Caterpillar Built Machines System Overview
C9 Engine for the 816F Series 2 Landfill Compactor, the 815F Series 2 Soil Compactor, and the 814F Series 2 Wheel Dozer Coolant Temperature Is High
C9 Engine for the 816F Series 2 Landfill Compactor, the 815F Series 2 Soil Compactor, and the 814F Series 2 Wheel Dozer Configuration Parameters
AD55B Underground Articulated Truck Power Train Electronic Control System Indicator Lamp for Body Up Does Not Illuminate During the Power Up Self Test
AD55B Underground Articulated Truck Power Train Electronic Control System Indicator Lamp for Body Up Is On Continuously
C9 Engine for the 816F Series 2 Landfill Compactor, the 815F Series 2 Soil Compactor, and the 814F Series 2 Wheel Dozer Electrical Power Supply - Test
C9 Engine for the 816F Series 2 Landfill Compactor, the 815F Series 2 Soil Compactor, and the 814F Series 2 Wheel Dozer Engine Top Speed Is Not Obtained
2007/03/12 Maintenance Instruction Has Been Added for HMU Steering {4310, 4343}
IT38H Integrated Toolcarrier and 938H Wheel Loader Engine Supplement Fan and Gear Motor (Hydraulic Fan) - Install
IT38H Integrated Toolcarrier and 938H Wheel Loader Engine Supplement Gear Motor (Hydraulic Fan) - Disassemble
D6T Track-Type Tractor Hydraulic System General Information
953D Track-Type Loader Hydraulic System Piston Pump (Implement)
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.