The Failure of the Buffer Seal that can be Caused by a Defect in the Seal Groove on All Track-Type Tractors, Wheel Loaders, Hydraulic Excavators and Backhoe Loaders that Use Cylinders that were Manufactured After 1January 2000{7562} Caterpillar


The Failure of the Buffer Seal that can be Caused by a Defect in the Seal Groove on All Track-Type Tractors, Wheel Loaders, Hydraulic Excavators and Backhoe Loaders that Use Cylinders that were Manufactured After 1January 2000{7562}

Usage:

D6D 01Y
Backhoe Loader: All
Excavator: All
Track-Type Tractor: All
Wheel Loader: All

Introduction

ReferenceThis technical information bulletin replaces a technical information bulletin that was written on 20October 2000. Please disregard Technical Information Bulletin, TIBU4388-00, "Buffer Seal Failure Caused by a Defect in the Seal Groove on all Medium and Large Track-Type Tractors, Large and Medium Wheel Loaders, Hydraulic Excavators, and Backhoe Loaders built after 1January 2000". Refer to the following technical information bulletin.

Problem

Information from the field has indicated that the backup ring for the buffer seal can wear a step in the groove for the buffer seal in the cylinder head that causes the buffer seal to fail. This causes leaking from the rod end of the cylinder. The material for the backup ring is not as hard as the head material. In some applications, the backup ring wears the head material. The groove has only been seen in cylinder heads that contain the new buffer seals that are yellow.




Illustration 1g01327275

Refer to Illustration 1. Step (1) in the groove for the buffer seal will be found in the corner of the groove for the buffer seal. The failures that have been seen in the field have been found after the cylinder head has accumulated many hours of operation. When you install new seals in a leaking cylinder, it is possible that the wear groove would not be detected because the wear is located in an interior groove in the head.

Solution




Illustration 2g01327277

When you install new seals in a cylinder for any reason, perform a thorough inspection on any cylinder head that uses the new design of seals that are yellow. Determine if there is a groove or a recessed area on the edge of the groove for the buffer seal. If a defect is found, replace the head. Refer to Illustration 2. If seal groove (2) does not have any wear, Reuse the head.

Caterpillar Information System:

D5R Track-Type Tractor Hydraulic System Line Relief and Makeup Valve
D6K Track-Type Tractor Electrohydraulic Power Train Electrical Output Components
D6K Track-Type Tractor Electrohydraulic Power Train Electrical Input Components
D6K Track-Type Tractor Electrohydraulic Power Train Features
PL61 Pipelayer and D6K Track-Type Tractor MID 039 - CID 1884 - FMI 04
D6K XL with Foldable Blade{6060} D6K XL with Foldable Blade{6060}
C11 and C13 Engines and 14M and 16M Motor Graders Oil Pressure Is Low
Installation of Ripper (S/N: 404){6310} Installation of Ripper (S/N: 404){6310}
AD55B Underground Articulated Truck Machine Systems Gear Pump (Hoist, Brake, and Pilot) - Disassemble
D6K Track-Type Tractor Electrohydraulic Power Train Warning Operation
657G Wheel Tractor-Scraper Auger Hydraulic System Piston Pump (Auger)
657G Wheel Tractor-Scraper Auger Hydraulic System Gear Pump (Auger)
2007/01/22 Genuine Track Shoes Are Being Replaced with Classic Track Shoes {4172}
953K Track-Type Loader Machine Systems Sensors - Remove and Install
D6K Track-Type Tractor Electrohydraulic Power Train Electronic Control Module (Machine)
D6K Track-Type Tractor Machine Systems Fuel Tank - Remove
973C Track-Type Loader Hydrostatic Drive Oil - Change
953D Track-Type Loader Machine Systems Refrigerant Accumulator - Remove and Install
953D Track-Type Loader Machine Systems Receiver-Dryer - Remove and Install
963D Track-Type Loader Machine Systems Lift Cylinder - Remove and Install
Installation of the V-PAT Bulldozer{6079} Installation of the V-PAT Bulldozer{6079}
PL61 Pipelayer and D6K Track-Type Tractor Implement System - D6K
953D Track-Type Loader Machine Systems Air Conditioner and Heater Components - Remove
953D Track-Type Loader Machine Systems Air Conditioner and Heater Components - Install
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.