Cylinder Head
Show/hide table
图 1 | g01345226 |
典型实例 |
用干净的发动机机油润滑螺纹和螺栓头的下部。
- 按图 1 中所示的顺序将螺栓上紧到以下扭矩。 ... 50 N·m (37
lb ft)
- 再次将螺栓拧紧至以下扭矩。 ... 100 N·m (74 lb ft)
- 将螺栓头拧紧到附加量。 ... 225 度
- 再次将螺栓拧紧至以下扭矩。 ... 100 N·m (74 lb ft)
缸盖最小厚度 ... 94.80 mm (3.7323 in)
Show/hide table
图 2 | g01345227 |
典型实例 |
注: 表 1 中给出了缸盖的最大变形。
Show/hide table
尺寸     | 最大允许变形     |
---|---|
宽度 (A)     | 0.03 mm (0.0012 in)     |
长度 (B)     | 0.05 mm (0.0020 in)     |
对角线 (C)     | 0.05 mm (0.020 in)     |
Show/hide table
图 3 | g01345230 |
典型实例 |
(C) 气门导管孔
- 进气和排气 ... 5.979 至 5.992 mm (0.2354 至 0.2359 in)
(D) 气门深度
- 进气 ... 0.905
至 1.163 mm (0.0356 至 0.0458 in)
- 进气门深度的维修极限 ... 1.41 mm (0.0555 in)
- 排气 ... 0.876 至 1.131 mm (0.0345 至 0.0445 in)
- 排气门深度的维修极限 ... 1.38 mm (0.0543 in)
- 进气门深度的维修极限 ... 1.41 mm (0.0555 in)
Caterpillar Information System:
3406E Marine Engine Flywheel - Install
3406E Marine Engine Flywheel - Remove
C27 and C32 Industrial Engines Model View Illustrations
C4.4 Marine Generator Set Engines Cylinder Head - Remove
C7 and C9 On-highway Engines Engine Crankcase Breather - Clean
G3400 Engines (EIS) Shutdown Relay
2006/03/20 270-5051 Repair Kit (Electrical Connectors) Available for Repairs to Wiring Harnesses with Ampseal 16 and A4E 2 Connectors {0709, 1408}
C7 and C9 On-highway Engines Safety Messages
C6.6 Industrial Engine Alternator
C6.6 Industrial Engine Starter Motor
C2.2 Engine and C1.5 Generator Set Electrical System
TH48-E80 Petroleum Transmission Magnetic Screen (Transmission) - Clean
C4.4 Marine Generator Set Engines Camshaft - Remove and Install
C3.3 and C4.4 Generator Sets Camshaft Gear - Remove and Install
C4.4 Marine Generator Set Engines Camshaft Bearings - Remove and Install
C7.1 Engines for Caterpillar Built Machines Cylinder Head Valves
Caterpillar On-Highway Diesel Engine Fluids Recommendations Aftermarket Oil Additives
C7 On-highway Engine Turbocharger Oil Lines
2005/05/23 New Ignition Harness {1408}
C13 and C15 On-highway Engines Coolant Temperature Is High
C7 On-highway Engine Air Compressor
3406E and C15 Marine Engines Cylinder Head - Remove
2005/05/09 New Flash Files are Available {7620}
3500 Engines with EUI Option Engine Design