0173-11 Very High Exhaust Gas Temperature Derate
产生此代码的情况:
该代码说明发动机额定功率已下降,以防排气温度过高。
发动机控制模块 (ECM) 将根据下述传感器送来的输入计算排气温度:
- 大气压力传感器
- 进气温度传感器
- 发动机转速/正时传感器
系统响应:
发动机额定功率下降超过 8% 后即记录该代码。 发动机只能降低额定功率到允许排气温度降至容许范围内的程度。 如果存在该事件代码的话,检查发动机指示灯不亮。
ECM 会使发动机额定功率下降运转。
测试步骤 1. 与驾驶员交流
注: 不需要进行发动机修理。
- 确定导致该故障诊断代码的状况。
预期结果:
发动机在重载和/或爬陡坡情况下运转。
结果:
- 正常 - 停止
Caterpillar Information System:
3406E, C-10, C-12, C-15, C-16 and C-18 On-highway Engines 0111-11 Very Low Coolant Level (62)
3516B HD Generator Set Generator Set Lifting
3406E, C-10, C-12, C-15, C-16 and C-18 On-highway Engines 0111-02 Coolant Level signal invalid (12)
G3600 Engines Engine Oil Lines - Electrohydraulic System
C9 Urban Transit Bus Engine Fuel System - Prime
3406E, C-10, C-12, C-15, C-16 and C-18 On-highway Engines 0111-01 Low Coolant Level Warning (62)
3054E Industrial Engine Air Compressor Idler Gear - Remove and Install
320B, 320B L and 320B N Excavators Final Drive Oil Sample - Obtain
C1.5 and C2.2 Generator Sets Fuel System - Prime
3054E Industrial Engine Crankshaft Timing Ring - Remove and Install
2002/12/01 The Color of Certain O-Ring Seals Is Changing {7555}
2003/01/01 The Color of Certain O-Ring Seals Is Changing {7555}
C9 Urban Transit Bus Engine Fuel System Water Separator - Drain
3126E Engine for Combat and Tactical Vehicles System Overview
C11, C13 and C15 On-highway Engines 0100-01 Low Oil Pressure Warning (46)
C11, C13 and C15 On-highway Engines 0100-11 Very Low Oil Pressure (46)
3512B Marine Auxiliary Engine Air Inlet and Exhaust Lines
3054E Industrial Engine Accessory Drive - Remove and Install
3126B Marine Engines Engine Will Not Crank
C1.5 and C2.2 Generator Sets Alternator Belt - Inspect/Adjust/Replace
C27 PET GEN SET Electric Power Generation and C27 KNOCKDOWN K Petroleum Power Train Package Battery or Battery Cable - Disconnect
3126B and 3126E On-highway Engines 0071-00 Idle Shutdown Override (01)
3126B and 3126E On-highway Engines 0071-01 Idle Shutdown (47)
3126B and 3126E On-highway Engines 0071-14 PTO Shutdown (47)