Slave Piston Lash - Adjust
Show/hide table
图 1 | g00751844 |
(1) 压缩制动器 (2) 螺钉 (3) 间隙调整活塞 |
- 将 1 号气缸置于上止点位置(压缩冲程)。 请参阅测试和调整, "查找 1 号活塞上止点位置"。
注: 间隙过大可导致制动器性能下降,没有间隙可导致排气门在发动机升温时打开。
- 通过执行以下步骤设定 1、3 和 5 号气缸的制动器间隙。
(a) 松开螺钉 (2) (多圈)的同时固定间隙调整活塞 (3) 。
(b) 逆时针转动间隙调整活塞 (3) ,直到制动器调整螺钉 (4) 接触排气门桥销 (5) 的顶部。
(c) 顺时针回调间隙调整活塞 (3) 一整圈加 90 度。 请参阅图 94。
(d) 固定间隙调整活塞 (3) 。 将螺钉 (2) 上紧到 4.5 ± 0.5 N·m (40 ± 4 lb in) 的扭矩。
Show/hide table
图 2 | g00752158 |
(5) 气门桥销 (6) 气门桥 |
Show/hide table
图 3 | g00754414 |
顺时针转动间隙调整活塞。 |
Show/hide table
图 4 | g00752391 |
(1) 压缩制动器 (2) 螺钉 (3) 间隙调整活塞 (4) 制动器调整螺钉 |
- 转动曲轴 360 度。 将 6 号气缸置于上止点位置(压缩冲程)。
- 设定 2、4 和 6 号气缸的制动器间隙。 通过执行步骤 2 设定 2、4 和 6 号气缸的制动器间隙。
Caterpillar Information System:
3524B Engines for 797 and 797B Off-Highway Trucks Engine Oil Pressure - Test
325D and 329D Excavators Ether Starting Aid Cylinder - Replace - If Equipped
VHS-10, VHS-30, VHS-40, VHS-50, VHS-60 and VHS-70 Demolition and Scrap Shears Speed Control Valve
VHS-10, VHS-30, VHS-40, VHS-50, VHS-60 and VHS-70 Demolition and Scrap Shears Speed Control Valve
M325B Excavator Machine System Specifications Control Valve (Main)
322C Excavator Engine Oil and Filter - Change
M325B Excavator Machine System Specifications Lines (Travel Motor) - Upper
VHS-10, VHS-30, VHS-40, VHS-50, VHS-60 and VHS-70 Demolition and Scrap Shears Hydraulic Cylinder
VHS-10, VHS-30, VHS-40, VHS-50, VHS-60 and VHS-70 Demolition and Scrap Shears Hydraulic Cylinder
VHS-10, VHS-30, VHS-40, VHS-50, VHS-60 and VHS-70 Demolition and Scrap Shears Hydraulic Cylinder
M325B Excavator Machine System Specifications Lines (Heater)
322C Excavator Engine Oil Level - Check
3406E and 3456 Engines for Caterpillar Built Machines Speed and Timing Sensor
320C Excavator Access Door and Cover Locations
322C Excavator Fuel System Filter - Replace
2000/11/06 Correction of the Disassembly and Assembly Manual for the Installation of the Main Hydraulic Pump and Pump Drive Coupling {5062, 5070}
2000/10/30 The Spring Seat Washer Is Now A Serviceable Component Of The Rocker Arm Cover Base Assembly {1102}
5110B Excavator Bucket Linkage - Inspect/Adjust
315C Excavator Cab Visor - If Equipped
322C Excavator Fuel System - Prime
307B Excavator VA Boom Controls
325C and 325C L Excavator Fuel System Water Separator - Drain
320C Excavator Storage Box
M325B Material Handler Power Train Travel Motor - Remove