Front Axle - Install and Adjust
Show/hide table
图 1 | g01524365 |
(1) 撑杆 (2) 垫片 (3) 板 (4) 螺栓 |
- 将 4C-5593 防粘结剂 涂覆在撑杆 (1) 的锥面上。 将轴组装到撑杆 (1) 上。 安装板 (3) 。 使用间隔 120 度的三颗螺栓 (4) 和垫圈来安装板 (3) 。 此时请勿使用垫片 (2) 。 将螺栓 (4) 拧紧至扭矩为 200 ± 10 N·m (145 ± 7 lb ft)。
- 在板 (3) 的三个螺纹孔上使用深度千分尺。 测量从撑杆 (1) 末端到板 (3) 外表面的距离。 记录测量结果的平均值。
- 拆下螺栓 (4) 、垫圈和板 (3) 。 在进行上一次测量的螺栓孔附近测量板 (3) 的厚度。 计算板 (3) 的平均厚度。
Show/hide table
处置支撑杆比较危险,可能会造成人员伤亡。 拆卸板组件时,突然从支撑杆上释放心轴或者螺栓突然折断,可能会造成人身伤害。 将所有螺栓每次旋松半圈,如此循环来拆卸板组件。 重复执行此操作,直到螺栓扭矩得以释放。 |
- 安装垫片组 (2) 。 为了确定垫片组厚度,从步骤 2 和步骤 3 的平均测量值的差中减去 9.30 ± 0.03 mm (0.3661 ± 0.0012 in)。
注: 垫片组厚度必须不小于 1.00 mm (0.040 in)。
- 安装垫片 (2) 、板 (3) 和螺栓 (4) 。 将螺栓 (4) 拧紧至 3100 ± 350 N·m (2300 ± 260 lb ft)。
Caterpillar Information System:
C7 Engines for Caterpillar Built Machines Unit Injector Hydraulic Pump
2008/07/07 Correction to Systems Operation Testing and Adjusting , "Ride Control System" {5004}
2008/07/07 Correction to Systems Operation Testing and Adjusting , "Main Hydraulic System" {5050}
D6K Track-Type Tractor Electrohydraulic Power Train Hydraulic Tank
2008/07/07 Correction to Systems Operation Testing and Adjusting , "General Information" {5050}
785D Off-Highway Truck Reference Material
416E, 420E and 430E Backhoe Loaders Engine Supplement Radiator, Refrigerant Condenser, and Hydraulic and XMSN Oil Cooler - Install
2008/05/05 An Improved Indicator for the Hydraulic Oil Filter is Available for Cold Planers {5068, 7450}
CB-434D, CB-534D and CB-564D Asphalt Compactors Electronic Control Module (ECM) - Flash Program
AP600D and BG600D Asphalt Pavers C6.6 Engine Supplement Radiator and Hydraulic Oil Cooler - Remove and Install
795F AC and 795F AC XQ Off-Highway Truck Steering System Steering Control Valve - Adjust
793F and 793F CMD Off-Highway Truck Air System Relay Valve (Air Start)
795F AC and 795F AC XQ Off-Highway Truck Steering System Front Wheel Bearing - Adjust
PL61 Pipelayer Machine Systems Control Valve (Implement)
793F and 793F CMD Off-Highway Truck Hydraulic System Cab Mounting
795F AC and 795F AC XQ Off-Highway Truck Steering System Worksheets
CD54 Paving Compactor Battery - Clean/Check
3516B Engine for 994F and 994H Wheel Loaders Speed/Timing - Test
785D OEM Off-Highway Truck VIMS Module Battery - Replace
795F AC and 795F AC XQ Off-Highway Truck Steering System Solenoid and Relief Valve (Steering)
Procedure to Test the Electrical System on Asphalt Screeds{7610, 7620} Procedure to Test the Electrical System on Asphalt Screeds{7610, 7620}
AP655D Asphalt Paver Machine Systems Piston Pump (Right Drag Conveyor and Right Auger Conveyor) - Remove
AP655D Asphalt Paver Machine Systems Piston Pump (Right Drag Conveyor and Right Auger Conveyor) - Install
2008/05/12 A New Procedure is Available to Test the Electrical System on Asphalt Screeds {1408, 6643, 664E}