Extender Carriage
Show/hide table
Illustration 1 | g01298125 |
(1) Apply 9S-3263 Thread Lock Compound to the twenty-four 8T-8917 Bolts.
(2) Apply 9S-3263 Thread Lock Compound to the four 5S-2389 Bolts.
(3) Apply 4C-5593 Anti-Seize Compound and tighten the inboard 8I-0184 Adjustment Nut to the following torque. ... 150 ± 10 N·m (110 ± 7 lb ft)
(3) Apply 4C-5593 Anti-Seize Compound and tighten the remaining two 8I-0184 Adjustment Nuts to the following torque. ... 30 ± 10 N·m (22 ± 7 lb ft)
(4) Tighten the six ID-5118 Nuts to the following torque. ... 200 ± 40 N·m (150 ± 30 lb ft)
(5) Apply 7X-7699 Lubricating Grease to the wear plates. There are four wear plates on each extender.
(6) Apply 9S-3263 Thread Lock Compound to the twenty-four 8T-9389 Bolts.
Caterpillar Information System:
IT38H Integrated Toolcarrier and 938H Wheel Loader Cab Air Filter - Clean/Replace
IT38H Integrated Toolcarrier and 938H Wheel Loader Axle Oil Cooler Magnetic Filter - Clean/Replace
2006/08/14 A New Saw Pump Is Used on Track Feller Bunchers {5070}
C-9 Engines for Caterpillar Built Machines Speed/Timing Sensor
PL61 Pipelayer Fuel System Primary Filter - Clean/Replace
C15 Petroleum Generator Set Engines Inlet Air Temperature Sensor
TK711, TK721, TK722, TK732, TK741, TK751 and TK752 Track Feller Bunchers IQAN MDM Monitor Fault ; Event Codes Input High Error IQAN XT2 A0-25
793D Off-Highway Truck Power Train Flow Control and Relief Valve (Rear Axle Oil) - Assemble
793D Off-Highway Truck Power Train Flow Control and Relief Valve (Rear Axle Oil) - Disassemble
572R Series II Pipelayer Transmission Magnetic Screen - Clean
Procedure for Kidney Looping Wheel Harvester and Site Prep Tractor Hydraulic Oil{0680, 0738, 0768, 3000, 5050, 5056} Procedure for Kidney Looping Wheel Harvester and Site Prep Tractor Hydraulic Oil{0680, 0738, 0768, 3000, 5050, 5056}
2006/08/14 An Improved Weld Is Now Used on the Undercarriage on Track Feller Bunchers {4150}
777G Off-Highway Truck Power Train Duo-Cone Seals - Install
2006/11/06 New Seal Kit for Fan Motors {1386, 5061}
PM-201 Cold Planer Rotor Coolant Level - Check - Drum with Three-Piece Rotor Bits
IT38H Integrated Toolcarrier and 938H Wheel Loader Engine Crankcase Breather - Clean - If Equipped
IT38H Integrated Toolcarrier and 938H Wheel Loader Fuel Tank Water and Sediment - Drain
120M, 12M, 140M and 160M Motor Graders Power Train Pressure Switch (Parking Brake)
770, 772, 773E, 773F, 777E and 777F Off-Highway Trucks and 775F Quarry Truck VIMS Truck Payload System Connector Contact Description
PM-200 Cold Planer Rotor Cutter Bits - Inspect/Replace - Drum with Three-Piece Rotor Bits
120M, 12M, 140M and 160M Motor Graders Power Train Solenoid Valve (Parking Brake)
773F, 773F OEM, 777F and 777F OEM Off-Highway Trucks and 775F and 775F OEM Quarry Truck Vital Information Management System (VIMS) System Schematic
770, 772, 773E, 773F, 777E and 777F Off-Highway Trucks and 775F Quarry Truck VIMS Truck Payload System CID 0267 - FMI 01
770, 772, 773E, 773F, 777E and 777F Off-Highway Trucks and 775F Quarry Truck VIMS Truck Payload System CID 0533 - FMI 02