1. Home
  2. Caterpillar
  3. Operation and Maintenance Manual
  4. #i02020397

CP-323C and CS-323C Paving Compactors Caterpillar


Battery or Battery Cable - Inspect/Replace

Usage:

CS-323C DAR

  • Turn the engine start switch to the OFF position. Turn all switches to the OFF position.

  • Turn the battery disconnect switch to the OFF position. Remove the battery disconnect switch key.
    Show/hide table
    Illustration 1g01043509

  • The battery compartment is located at the rear of the machine in the engine compartment.

  • Remove the covers for the batteries.

  • At the battery disconnect switch, disconnect the negative battery cable that is connected to the frame.

    Note: Do not allow the disconnected battery cables to contact the disconnect switch. Do not allow the disconnected battery cables to contact the other cables. Do not allow the disconnected battery cables to contact the opposite terminal of either battery.

  • Disconnect the negative battery cable at the battery.

  • Disconnect the positive battery cable from the battery.

  • Remove the positive cable from the starter motor.

  • Remove the cable that connects the two batteries together.

  • Perform the necessary repairs. Replace the cables or the batteries, as needed.

  • Reverse the above steps in order to reconnect the batteries.

  • Connect the battery cable at the battery disconnect switch.

  • Install the battery disconnect switch key.

  • Install the battery compartment covers.

  • Turn the battery disconnect switch to the ON position.

    • Caterpillar Information System:

    C15 and C18 Engines for Caterpillar Built Machines Engine Oil Pump - Remove
    CP-323C and CS-323C Paving Compactors Battery - Clean/Check
    CAES ULTRA Machine Control ; Guidance Products Computer Aided Earthmoving System Digital Terrain Model
    CAES ULTRA Machine Control ; Guidance Products Computer Aided Earthmoving System Switches
    CAES ULTRA Machine Control ; Guidance Products Computer Aided Earthmoving System Annunciator
    CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Hydraulic Oil Cooler - Remove and Install
    CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Hydraulic Tank - Remove and Install
    R2900G Load Haul Dump Power Train Electronic Control System Solenoid Valves
    CP34 and CS34 Vibratory Soil Compactors Axle Oil Sample - Obtain
    C15 and C18 Engines for Caterpillar Built Machines Turbocharger - Assemble
    C15 and C18 Engines for Caterpillar Built Machines Turbocharger - Disassemble
    CP34 and CS34 Vibratory Soil Compactors Axle Oil Level (Rear) - Check
    CP-323C and CS-323C Paving Compactors Circuit Breakers - Reset
    3524B Engines for 797 and 797B Off-Highway Trucks Cold Mode Operation
    C15 and C18 Engines for Caterpillar Built Machines Engine Oil Pump - Install
    C15 On-Highway Engine Engine Oil Pump - Disassemble
    C15 On-Highway Engine Engine Oil Pump - Assemble
    914G and 914G2 Compact Wheel Loaders and IT14G and IT14G2 Integrated Toolcarrier Hydraulic System Relief Valve (Line) - Test and Adjust
    2004/03/29 Special Instruction, REHS1037 , "Installation Instructions for the Electric Fuel Priming Pump on Caterpillar Equipment With the 24 Volt System" has been Revised {1258}
    CP-323C and CS-323C Paving Compactors Cooling System Coolant (ELC) - Change
    CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Gear Pump (Steering) - Remove
    CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Gear Pump (Steering) - Disassemble
    CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Gear Pump (Steering) - Assemble
    CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Gear Pump (Steering) - Install
    Back to top
    Contacts My AVS
    The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
    CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.