Fuel System Primary Filter - Replace
Show/hide table
NOTICE |
---|
Do not fill fuel filters with fuel before installing them. Contaminated fuel will cause accelerated wear to fuel system parts. |
- Open the engine access door on the back side of the machine. Use the prop rod to hold the engine access door open. The fuel filter is located on the right side of the engine compartment on the back side of the machine.
Show/hide table
Illustration 1 | g00387726 |
Show/hide table
Illustration 2 | g00448380 |
- Remove the cap (1), the top plate, the O-ring, and the bayonet. This stops the flow of fuel into the filter element.
Show/hide table
Illustration 3 | g00398196 |
- Support the filter element (3) and rotate the locking ring (2) counterclockwise. Remove the locking ring.
- Remove the fuel filter. Inspect the fuel filter for debris by cutting the filter open. Discard the filter properly.
- Clean the mounting base of the fuel filter. Remove any part of the old seal that remains on the mounting base of the fuel filter.
- Coat the seal of the new fuel filter with clean diesel fuel.
- Install the new fuel filter by hand. Rotate the locking ring clockwise.
- Replace the bayonet, the O-ring, the top plate, and the cap.
- Prime the fuel system. Refer to Operation and Maintenance Manual, "Fuel System Priming Pump - Operate".
- Close the engine access door.
Caterpillar Information System:
914G Wheel Loader Equipment Lowering with Engine Stopped
572R Pipelayer Battery Disconnect Switch
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Power Train Oil Distribution To Clutch
IT14G Integrated Toolcarrier Engine Oil and Filter - Change
793B Off-Highway Truck Power Train Torque Converter Lockup Clutch Signal Pressure - Test
572R Pipelayer Horn
IT14G Integrated Toolcarrier Engine Oil Level - Check
IT14G Integrated Toolcarrier Engine Crankcase Breather - Clean
572R Pipelayer Light Switches
IT14G Integrated Toolcarrier Engine Air Filter Service Indicator - Inspect
3406E and 3456 Industrial Engines Exhaust Manifold
IT14G Integrated Toolcarrier Engine Air Filter Secondary Element - Replace
IT14G Integrated Toolcarrier Fuel System Priming Pump - Operate
IT14G Integrated Toolcarrier Fuel System Water Separator - Drain
IT14G Integrated Toolcarrier Fuel System Water Separator Element - Replace
IT14G Integrated Toolcarrier Fuel Tank Cap - Clean
IT14G Integrated Toolcarrier Hydraulic System Oil Filter - Replace
IT14G Integrated Toolcarrier Hydraulic System Oil Level - Check
572R Pipelayer Power Train Final Drive
IT14G Integrated Toolcarrier Lubricant Viscosities
572R Pipelayer Backup Alarm
IT14G Integrated Toolcarrier Parking Brake Manual Release
784B and 785B Off-Highway Truck/Tractors Truck Payload Measurement System (TPMS)
C15 and C18 Petroleum Generator Sets Ether Starting Aid Cylinder - Replace - If Equipped