Control Box - Remove and Install
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | - | Loctite RTV 透明硅密封胶 | - |
- 断开线束组件 (1)。
Show/hide table
图 2 g03805442 - 断开线束组件 (2)。
Show/hide table
图 3 g03805474 - 断开线束组件 (3)。
Show/hide table
图 4 g03805495 - 断开线束组件 (4)。
Show/hide table
图 5 g03805506 - 拆下螺钉 (5) 和螺钉 (6)。 将线束组件 (8) 安置在旁边。
- 拆下螺栓 (7) 和线束组件 (9)。
Show/hide table
图 6 g03805591 - 连接适当的起吊设备以拆下仪表板安装件 (10) 和接线盒 (11)。
- 拆下螺栓 (12)。
Show/hide table
图 7 g03805598 - 拆下螺栓 (13)、螺栓 (14)、仪表板安装件 (10) 和接线盒 (11)。 仪表板安装件 (10) 和接线盒 (11) 的重量约为
91 kg (201 lb) 。Show/hide table图 8 g03805623 - 将适当的起吊设备连接到仪表板安装件 (10) 上。
- 拆下螺栓 (15)、螺栓 (16) 和仪表板安装件 (10)。 仪表板安装件 (10) 的重量约为
35 kg (77 lb) 。
Show/hide table
图 1 | g03805368 |
- 按与拆卸相反的顺序安装接线盒 (11)。
- 将工具 (A) 涂敷在螺栓 (16)、螺栓 (15) 和螺栓 (7) 的螺纹上。
Caterpillar Information System:
C3.4B Engines for Caterpillar Built Machines Position the Valve Mechanism Before Maintenance Procedures
C3.4B Engines for Caterpillar Built Machines Engine Valve Lash - Inspect
C3.4B Engines for Caterpillar Built Machines Glossary of Electronic Control Terms
C3.4B Engines for Caterpillar Built Machines Power Sources
C3.4B Engines for Caterpillar Built Machines Electronic Control System
C3.4B Engines for Caterpillar Built Machines Introduction
C18 Generator Set Generator Bearing Temperature - Test/Record
2015/03/25 ECOS Active Bypass Upgrade Kits Are Available for Certain G3520C 1200 rpm Engines {1057, 1269, 1403, 1439}
2015/02/27 A New Special Instruction Is Available for the Compressed Air Packaged System Used on Certain3516C and C175 Tier 4I Generator Sets {1803}
G3612 and G3616 Engines Hydraulic Tank (Hydrax) - Remove and Install
G3612 and G3616 Engines Hydraulic Oil Pump (Hydrax) - Remove and Install
794 AC Off-Highway Truck Field Assembly Introduction
DE Series Generator Set With Cat C4.4 Engine Control Panel
Marine Selective Catalytic Reduction (SCR) Retrofit Aftertreatment Filter Screen (DEF) - Inspect/Clean
C18 Generator Set Engine Protective Devices - Check
C3.4B Engines for Caterpillar Built Machines Diesel Exhaust Fluid Tank - Flush
C3.4B Engines for Caterpillar Built Machines Aftertreatment SCR System Dosing - Test
3512E Tier 4 Final Engines for Land Electric Drilling Injector Solenoid - Test
G3516 TA Engine ECM - Replace
C13 Engines Plate Locations and Film Locations
C13 Engines Emissions Certification Film
DE Series Generator Sets With Cat C3.3 Engine Maintenance Interval Schedule - Prime Power
DE Series Generator Sets With Cat C3.3 Engine Maintenance Interval Schedule - Standby
C13 Engines Reference Information