Coolant Level - Check
发动机停机并冷却后检查冷却液液位。
Show/hide table
图 1 | g00285520 |
冷却系统加注口盖 |
Show/hide table
加压的系统: 热的冷却液能造成严重的烫伤。 在发动机停机,等待冷却系统部件冷却下来后再打开冷却系统加注口盖。 缓慢松开冷却系统加注口盖,以释放掉所有压力。 |
- 慢慢拆下冷却系统加注口盖,以释放掉压力。
- 将冷却液液位保持在距加注管底部 13 mm (0.5 in) 以内。 如果发动机配备了观察孔,保持冷却液液位在观察孔内适当的水平。
- 清洁冷却系统加注口盖,检查加注口盖密封垫的状况。 如果加注口盖密封垫损坏,更换冷却系统加注口盖。 重新安装冷却系统加注口盖。
Show/hide table
图 2 | g00103639 |
典型加注口盖密封垫 |
- 检查冷却系统有无泄漏。
Caterpillar Information System:
DE Series Generator Set With Cat C4.4 Engine Engine - Clean
C7 Industrial Engine Air Shutoff - Test
DE Series Generator Set With Cat C4.4 Engine Battery - Replace
3512C HD and 3516C HD IPP Rental Power Modules Intake Manifold Air Temperature Is High
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Sensor Signal (PWM) - Test
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Sensor Supply - Test
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Speed/Timing - Test
3512C HD and 3516C HD IPP Rental Power Modules Fuel Pressure Is Low - Diesel System
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Starting - Test
3512C HD and 3516C HD IPP Rental Power Modules Fuel Filter Is Restricted
Thickness of the 102-5861 Thrust Plate Is Out of Specification on Certain 3400 Series Commercial and Machine Engines{1210} Thickness of the 102-5861 Thrust Plate Is Out of Specification on Certain 3400 Series Commercial and Machine Engines{1210}
DE Series Generator Set With Cat C4.4 Engine Belt Tensioner - Check - Poly V-Belt
DE Series Generator Set With Cat C4.4 Engine Engine Valve Lash - Check
DE Series Generator Set With Cat C4.4 Engine Battery or Battery Cable - Disconnect
DE Series Generator Set With Cat C4.4 Engine Generator - Dry
DE Series Generator Set With Cat C4.4 Engine Generator Load - Check
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Sensor Signal (Analog, Passive) - Test
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Sensor Signal (Analog, Active) - Test
DE Series Generator Set With Cat C4.4 Engine Generator Set - Test
DE Series Generator Set With Cat C4.4 Engine Rotating Rectifier - Check
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Fuel Actuator - Test
C9.3 Marine Auxiliary Engines Engine Crankcase Breather - Clean
DE Series Generator Set With Cat C4.4 Engine Rotating Rectifier - Inspect/Test
3512C Marine Auxiliary Generator Set Engines with Dynamic Gas Blending Exhaust Temperature - Test