Receiver Dryer (Refrigerant) - Remove and Install
拆卸步骤
- 回收空调系统中的空调制冷剂。 请参阅维修手册, SENR5664, "使用 R-134a 制冷剂的空调与暖风系统",了解相关正确步骤。 有关正确的工具,请参阅专门出版物, NEDG2500, "空调工具"。
Show/hide table
接触制冷剂会使人受伤。 此系统永远处于加压状态,即便发动机没有工作也是如此。 切勿让已加注制冷剂的系统受热。 接触制冷剂会造成冻伤。 让手、脸避开有助于防止受伤。 制冷管路打开时,须始终佩带护目镜,即便压力计显示系统中已经没有制冷剂,也须佩带。 取下接头时务必小心谨慎。 慢慢地拧松接头。 如果此系统仍然有压力,请抽空系统,回收制冷剂,然后再拆下接头。 通过点燃的香烟吸入制冷剂会导致人身伤害或死亡。 通过点燃的香烟或其他抽烟方法吸入空调制冷气体,或吸入燃烧空调制冷气体形成的烟雾,都会导致人身伤害或死亡。 维修空调时,或在任何可能存在制冷气体的情况下都不要抽烟。 请先将机器移至平坦的地方,然后再对空调和加热系统进行检查。 把所有机具降到地面。 确保变速箱处于空档或停车位置,确保停车制动器接合。 让所有其他人员远离机器。 |
- 打开发动机罩。
- 打开机器左侧的检修门 (1) 。
Show/hide table
图 1 | g01441433 |
- 断开管组件 (2) 和 (3) 。
Show/hide table
图 2 | g01442842 |
- 拆下卡箍 (4) 和 (6) 。 拆下制冷剂干燥和储液罐 (5) 。
安装步骤
- 定位制冷剂干燥和储液罐 (5) 并安装卡箍 (4) 和 (6) 。
Show/hide table
图 3 | g01442842 |
- 连接管组件 (2) 和 (3) 。
- 关闭机器左侧的检修门 (1) 。
Show/hide table
图 4 | g01441433 |
- 关闭发动机罩。
End By: 加注空调系统。 请参阅 维修手册SENR5664"使用 R-134a 制冷剂的空调与暖风系统",了解相关正确步骤。 有关正确的工具,请参阅 专门出版物NEDG2500"空调工具"。
Caterpillar Information System:
307D Excavator Engine Oil and Filter - Change
307D Excavator Engine Oil Level - Check
311D LRR Excavator Engine Supplement Refrigerant Condenser - Remove and Install
307D Excavator Cooling System Coolant (ELC) - Change
311D LRR Excavator Engine Supplement Turbocharger - Remove and Install
311D LRR Excavator Engine Supplement Battery - Remove and Install
307D Excavator Circuit Breakers - Reset
311D LRR Excavator Engine Supplement Air Cleaner - Remove and Install
Procedure to Retrofit the 385B UHD Machines with the New Fore Boom Control Valve{5051, 5057, 5117, 5461} Procedure to Retrofit the 385B UHD Machines with the New Fore Boom Control Valve{5051, 5057, 5117, 5461}
Assembly Instructions for Installing The Air Mix Door {7304, 7320} Assembly Instructions for Installing The Air Mix Door {7304, 7320}
311D LRR Excavator Engine Supplement Fuel Filter (Secondary) and Fuel Filter Base - Remove and Install
311D LRR Excavator Engine Supplement Fuel Filter and Water Separator Base - Remove and Install
307D Excavator Fuel System Primary Filter (Water Separator) Element - Replace
307D Excavator Fuel System Water Separator - Drain
H35D S, H45D S, H55D S and H65D S Hydraulic Hammers Hydraulic Accumulator (Low Pressure) - Test and Charge
307D Excavator Fuel Tank Water and Sediment - Drain
307D Excavator Travel Alarm - Test - If Equipped
345C Excavator and 345C Material Handler Machine System Specifications Stick - 9.1 m (29.86 ft)
311D LRR Excavator Machine Systems Relief Valve (Pilot) - Remove and Install
307D Excavator Hydraulic System Oil - Change
311D LRR Excavator Machine Systems Oil Filter and Base - Remove and Install
307D Excavator Hydraulic System Oil Filter (Pilot) - Replace
2008/06/16 A New Holding Bracket for the Muffler Is Now Used {1062}
345C Material Handler Hydraulic System Cab Riser Hydraulic System - Hydraulic Cab Riser