Engine Oil Scavenge Pump - Install
Show/hide table
| 注意 |
|---|
|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 将适当的吊具系缚到机油回油泵 (8) 上，并将机油回油泵 (8) 放置到位。 回油泵 (8) 的重量约为
32 千克 (71 磅) 。 安装螺栓 (9)。 - 将弯管 (10) 放置到位，然后安装螺栓 (11)。
Show/hide table
图 2 g01205694 - 将清洁的发动机机油涂在 O 形密封圈 (7) 上，再将此 O 形密封圈 (7) 安装到管 (6) 上。
- 安装管 (6)。 用管夹、垫圈和螺栓 (5) 固定管 (6)。
Show/hide table
图 3 g01205685 - 放正盖 (4)，然后安装螺栓 (3)。
- 清洗两块滤网，并将这两块滤网安装到壳体 (2) 中。 安装螺栓 (1)。
Show/hide table
| |
| 图 1 | g01205699 |
结束:
- 安装发动机油底壳。 请参考拆卸和组装, "发动机油底壳 － 安装"部分。
Caterpillar Information System:
320D and 323D Excavators Hydraulic System Swing Speed and Swing Drift on a Slope - Check
320D and 323D Excavators Hydraulic System Swing Speed and Overswing on Level Ground - Check
320D RR Excavator and 320D RR Forest Machine Hydraulic System Travel on Level Ground - Test - Optional Test
2005/09/26 A New Fuel Lift Pump is Now Available {1256, 1258}
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit Machine Systems Pilot Valve (Joystick) - Assemble
320D and 323D Excavators Hydraulic System Travel on Level Ground - Test
320D RR Excavator and 320D RR Forest Machine Hydraulic System Operational Checks
PP120 and PH126 Power Pack and Hammer Hydraulic Hand Control - Assemble
PP120 and PH126 Power Pack and Hammer Hydraulic Hand Control - Disassemble
M325D MH Material Handler Air Conditioning and Heating Control
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit Machine Systems Pilot Valve (Joystick) - Disassemble
3500 and 3500B High Displacement Engines for Caterpillar Built Machines Engine Oil Scavenge Pump - Remove
324D, 325D, 326D and 329D Excavators and 329D MHPU Mobile Hydraulic Power Unit Machine Systems Relief Valve (Pilot) - Remove
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System General Information
320D RR Excavator and 320D RR Forest Machine Hydraulic System Cylinder Drift - Check - Loaded Bucket
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System System Operation
320D and 323D Excavators Hydraulic System Cylinder Speed - Check
324D, 325D, 326D and 329D Excavators and 329D MHPU Mobile Hydraulic Power Unit Machine Systems Relief Valve (Pilot) - Install
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Diagnostic Operation
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Refrigerant Compressor - Remove and Install
324D, 325D, 326D and 329D Excavators and 329D MHPU Mobile Hydraulic Power Unit Machine Systems Manual Valve (Auxiliary Shutoff) - Remove
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Electronic Control Module (Machine)
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Air Cleaner - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Alternator - Remove and Install