Accumulator (Brake) - Remove and Install
Removal Procedure
Start By:
- Tilt cab.
- Remove bottom guard (transmission).
Show/hide table
Accumulator may contain high pressure oil. Do not service the accumulator or any hydraulic lines until all of the pressure has been relieved. See the Service Manual for proper procedures. Failure to heed this warning could result in injury or death. |
- Drain the hydraulic oil. Refer to Operation and Maintenance Manual, ""Hydraulic System Oil – Change"" for the correct draining and filling procedures.
- Disconnect hose assembly (2). Remove bolts (1) .
Show/hide table
Illustration 1 | g03643556 |
- Remove bolts (3). Use two people remove accumulator (4). The weight of accumulator (4) is approximately 25 kg (55 lb).
Show/hide table
Illustration 2 | g03643553 |
Installation Procedure
- Install accumulator (4) in the reverse order of removal.
Caterpillar Information System:
RM500B Rotary Mixer Engine Oil Sample - Obtain
RM500B Rotary Mixer Engine Oil Level - Check
586C Site Prep Tractor Machine Systems Bypass Valve - Remove and Install - Cold Oil Bypass
824K Wheel Dozer, 825K Soil Compactor and 826K Landfill Compactor Machine Systems Pilot Oil Accumulator - Test and Charge
12M Series 3, 140M Series 3 and 160M Series 3 Motor Graders Machine Preparation for Troubleshooting
826K Landfill Compactor, 825K Soil Compactor and 824K Wheel Dozer Engine Supplement Fuel Manifold (ARD) - Remove and Install
424B Backhoe Loader Hydraulic and Steering System Bucket
16M Series 3 and 18M Series 3 Motor Graders Service Interval Chart
424B Backhoe Loader Rated Load
824K Wheel Dozer, 825K Soil Compactor and 826K Landfill Compactor Machine Systems Parking Brake Control
424B Backhoe Loader Axles, Differential and Brakes Wheel and Tire (Rear)
C4.4 Engines for Caterpillar Built Machines Alternator
826K Landfill Compactor, 825K Soil Compactor and 824K Wheel Dozer Engine Supplement Fuel Filter Bases and Priming Pump - Remove and Install
Water Delivery System and 777F WTR, 777G WTR and 785D WTR OEM Off-Highway Trucks Sensor Signal (Analog, Active) - Test
RM500B Rotary Mixer Engine Oil and Filter - Change
990K Wheel Loader Steering System
950M, 962M, 950M Z and 962M Z Wheel Loaders Main Control Valve - Assemble
826K Landfill Compactor, 825K Soil Compactor and 824K Wheel Dozer Engine Supplement Fuel Priming Pump and Primary Filter (Water Separator) - Remove and Install
CS56B, CP56B, CS66B, CS68B and CP68B Vibratory Soil Compactors Machine Systems Piston Pump (Propel) - Disassemble
RM500B Rotary Mixer Fuel System Primary Filter - Clean/Inspect/Replace
RM500B Rotary Mixer Fuel System Secondary Filter - Replace
824K Wheel Dozer, 825K Soil Compactor and 826K Landfill Compactor Machine Systems System Pressure - Release
RM500B Rotary Mixer Fuel Tank Water and Sediment - Drain
RM500B Rotary Mixer Hydraulic System Oil Level - Check