Fuel System Water Separator Element - Replace - Fuel System Primary Filter Element
Show/hide table
Illustration 1 | g00708943 |
- Turn the valve (1) in a counterclockwise direction. Drain the fuel into a suitable container.
Note: Dispose of the waste in a proper manner.
Show/hide table
Illustration 2 | g00710144 |
- Close the valve (1) .
- Hold the bowl (5) while you loosen the collar (4). Remove the bowl (5) and the collar (5) .
- Loosen the collar (2). Remove the element (3). Discard the element in a proper manner.
Show/hide table
Illustration 3 | g00372835 |
- Clean the parts. Inspect the parts for damage. Replace the damaged parts or replace the worn parts.
- Install a new element. Tighten the collar (2) .
- Install the bowl (5) and tighten the collar (4) .
- Start the engine and check the fuel system for leaks.
- Close the door to the engine compartment.
Caterpillar Information System:
24H Motor Grader Transmission and Differential Oil - Change
CS-531D, CP-533D and CS-533D Vibratory Compactors Fuel System Water Separator - Drain
CS-531D, CP-533D and CS-533D Vibratory Compactors Propel System Piston Motor (Drum Propel)
3034 Engine for Caterpillar Built Machines Glow Plugs - Test
TH62, TH63, TH82 and TH83 Telehandlers Brake Control Linkage - Lubricate
980G Wheel Loader, 824G Wheel Dozer, 825G Soil Compactor and 826G Landfill Compactor Implement Electronic Control System Electronic Control Module (Implement)
TH62, TH63, TH82 and TH83 Telehandlers Light Switches
24H Motor Grader Transmission and Differential Oil Level - Check
2000/05/29 Tamper Proof Set Screws Are Used on Some 3054 Machine Engines {1251}
TH62, TH63, TH82 and TH83 Telehandlers Boom Pivot Shaft - Lubricate
CS-531D, CP-533D and CS-533D Vibratory Compactors Propel System Final Drive Planetary
D400E Series II Ejector Truck Wheel Bearings - Check/Adjust
CS-531D, CP-533D and CS-533D Vibratory Compactors Fuel Tank Breather - Replace
TH62, TH63, TH82 and TH83 Telehandlers Carriage Cylinder Bearing - Lubricate
TH62, TH63, TH82 and TH83 Telehandlers Directional Turn Signal, Window Washer and Wiper, and Dimmer Control
3508B and 3512B Engine Supplement for 776D, 777D, and 777D HAA Tractor/Off-Highway Trucks Aftercooler - Install
TH62, TH63, TH82 and TH83 Telehandlers Carriage Pivot Pin - Lubricate
CS-531D, CP-533D and CS-533D Vibratory Compactors Fuel Tank Cap and Strainer - Clean
D7R Series II Track-Type Tractor Transmission System Oil Sample - Obtain
2000/05/22 A New 24 Volt Glow Plug is Being Used {1408, 6642}
TH62, TH63, TH82 and TH83 Telehandlers Compensating Cylinder Bearing - Lubricate
3064 and 3066 Engines for Caterpillar Built Machines Battery - Test
CS-531D, CP-533D and CS-533D Vibratory Compactors Fuel Tank Water and Sediment - Drain
CS-531D, CP-533D and CS-533D Vibratory Compactors Hydraulic System Oil - Change