CID 0823 FMI 03 Lamp (Service) Voltage Above Normal - Test
Show/hide table
Illustration 1 | g00507787 |
Schematic of the VIMS service indicator lamp |
This diagnostic code is recorded when the VIMS module reads the voltage of the service indicator lamp circuit (E709-WH(White)) and the voltage is above normal. The service indicator lamp is ON CONTINUOUSLY as a result of this fault condition.
- CHECK THE LAMP CIRCUIT.
- Turn the key start switch and the disconnect switch to the OFF position.
- Disconnect the machine harness from the VIMS main module.
- Turn the disconnect switch to the ON position.
- Observe the service indicator lamp.
- Turn the key start switch to the ON position.
Expected Result: The service indicator lamp is ON.
Results:
- OK - The service indicator lamp turned ON. The harness circuit E709-WH(White) is shorted to the +battery. Repair the machine harness or replace the machine harness. STOP.
- NOT OK - The service indicator lamp is OFF. The VIMS interface module has failed. Replace the VIMS interface module. See Testing and Adjusting, "Module - Replace". STOP.
Caterpillar Information System:
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Implement, Steering and Brake Hydraulic Systems Steering Hydraulic System Operation
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0803 FMI 09 Interface Module (No. 3) Abnormal Update - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0802 FMI 09 Interface Module (No. 2) Abnormal Update - Test
836G Landfill Compactor and 834G Wheel Dozer Window Washer Reservoir - Fill
3408E and 3412E Engines for Caterpillar Built Machines Pistons and Connecting Rods - Remove
3406C Engines for Caterpillar Built Machines Camshaft Bearings
IT14G Integrated Toolcarrier and 914G Wheel Loader Engine Supplement Air Inlet Heater - Remove and Install
IT14G Integrated Toolcarrier and 914G Wheel Loader Engine Supplement Refrigerant Compressor - Remove and Install
IT14G Integrated Toolcarrier and 914G Wheel Loader Engine Supplement Pump Mounting - Remove and Install
C-10 and C-12 Industrial Engines Fuel Pressure Sensor
IT14G Integrated Toolcarrier and 914G Wheel Loader Engine Supplement Refrigerant Condenser Fans and Motor - Remove and Install
IT14G Integrated Toolcarrier and 914G Wheel Loader Engine Supplement Refrigerant Condenser - Install
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0823 FMI 05 Lamp (Service) Current Below Normal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0823 FMI 06 Lamp (Service) Current Above Normal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0809 FMI 02 Speedometer/Tachometer Module (No. 1) Incorrect Signal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0809 FMI 12 Speedometer/Tachometer Module (No. 1) Failed - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0810 FMI 02 Speedometer/Tachometer Module (No. 2) Incorrect Signal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0810 FMI 12 Speedometer/Tachometer Module (No. 2) Failed - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0811 FMI 02 Quad Gauge Module (No. 1) Incorrect Signal - Test
836G Landfill Compactor and 834G Wheel Dozer Window Wiper - Inspect/Replace
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0811 FMI 12 Quad Gauge Module (No. 1) Failed - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0812 FMI 02 Quad Gauge Module (No. 2) Incorrect Signal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0812 FMI 12 Quad Gauge Module (No. 2) Failed - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0813 FMI 02 Quad Gauge Module (No. 3) Incorrect Signal - Test