Flywheel - Remove - Equipped with Rear Power Take-Off
Show/hide table
所需工具 | |||
---|---|---|---|
工具 | 零件号 | 零件描述 | 数量 |
A | - | 导向螺柱 1/2 in - UNF x 4 in |
2 |
开始:
- 拆下电起动马达。 有关正确的步骤,请参阅拆解和组装, "电起动马达 - 拆卸和安装"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 拆下飞轮 (1) 上位置 (X) 的螺栓。
- 将工具 (A) 安装到飞轮 (1) 上的位置 (X)。
- 使用适当的起吊设备支承飞轮。 飞轮 (2) 的重量约为
68 kg (150 lb) 。 - 拆下其余的螺栓 (2)。
- 使用起吊设备将飞轮 (1) 从发动机上拆下。
- 拆下工具 (A)。
Show/hide table
图 2 g02062054 - 检查飞轮 (1) 和齿圈 (3) 有无磨损和损坏。 更换任何磨损或损坏的部件。
- 要拆下飞轮齿圈 (3),遵循步骤 8.a 至步骤 8.b。
- 将飞轮组件放置在适当的支架上。
- 使用锤子和冲头以将齿圈 (3) 从飞轮 (1) 上拆下。
注: 确定飞轮齿圈上轮齿的方位。
Show/hide table
图 1 | g02062053 |
Caterpillar Information System:
C7.1 Marine Engine Engine Oil Filter Base - Remove and Install - Non M.C.S. Arrangement
C7.1 Engines Flywheel - Install
C7.1 Engines Flywheel - Install - Equipped with Rear Power Take-Off
C7.1 Engines Flow Control Valve - Remove and Install
C7.1 Engines Fan Drive - Remove and Install
C7.1 Engines Fan - Remove and Install
C7.1 Engines Exhaust Manifold - Remove and Install - Top Mounted Exhaust Manifold
C7.1 Engines Exhaust Manifold - Remove and Install - Side Mounted Exhaust Manifold
C7.1 Engines Exhaust Elbow - Remove and Install
C7.1 Engines Engine Oil Pump - Remove
C7.1 Engines Engine Oil Pump - Install
C7.1 Engines Engine Oil Pressure Sensor - Remove and Install
C7.1 Engines Flywheel - Remove
C7.1 Engines Flywheel Housing - Remove and Install - Type A and Type B Wet Back End Housing
C7.1 Engines Flywheel Housing - Remove and Install - Flywheel Housing that is Equipped with Rear Power Take-Off
C7.1 Engines Front Cover - Remove and Install - Heavy Duty Front Cover
C7.1 Engines Front Cover - Remove and Install
C7.1 Engines Fuel Filter Base - Remove and Install
C7.1 Marine Engine Engine Oil Filter Base - Remove and Install - M.C.S. Duplex Engine Oil Filter Base
C7.1 Engines Fuel Injection Lines - Install
C7.1 Engines Fuel Injection Lines - Remove
C7.1 Engines Fuel Injection Pump - Install
C7.1 Engines Fuel Injection Pump - Remove
C7.1 Engines Fuel Injection Pump Gear - Install