Pressure for Transmission Lubrication - Test
采用以下测试测试变速箱润滑装置的油压。
Show/hide table
| |
| 图 1 | g01089423 |
Show/hide table
| 所需工具 | ||||
|---|---|---|---|---|
| 工具 | 项目 | 零件
编号 |
说明 | 数量 |
| A | A1 | 8T-0855 | 压力表 | 1 |
| A2 | 6V-3989 | 接头 | 1 | |
| A3 | 6V-4143 | 快速连接连接器 | 2 | |
| A4 | 177-7861 | 软管组件 | 1 | |
Show/hide table
| |
| 图 2 | g01686755 |
| (1) 润滑安全阀测压口 | |
可在变速箱前部的测压口 (1) 处测量变速箱润滑压力。
- 将工具 (A) 安装到测压口 (1) 上。
- 起动发动机。 预热机油直到机油达到
47 °C (116 °F) 。 - 以低怠速运转发动机。 观察压力表。 变速箱润滑压力值必须在系统操作、测试和调整, "动力传动系压力"中显示的值范围内。
- 以高怠速运转发动机。 观察压力表。 变矩器出口压力值必须在系统操作、测试和调整, "动力传动系压力"中显示的值范围内。
关闭发动机。
Caterpillar Information System:
3606 and 3608 Engines Magnetic Pickup
3606 and 3608 Engines Starting Motor - Protection
3606 and 3608 Engines Grounding Practices
3606 and 3608 Engines Electrical System Operation
3606 and 3608 Engines Air Starting System Operation
G3500B Engines Before Starting Engine
TH31-C9I, TH31-C9P, TH31-C9T, TH35-C11I, TH35-C13I, TH35-C13T, TH35-C15I and TH35-C15T Petroleum Power Train Packages and TH31-E61 and TH35-E81 Petroleum Transmissions Monitoring System General Information
TH48-E70-C27I, TH48-E70-C32I and TH48-E70-C32P Petroleum Power Train packages and TH48-E70 Petroleum Transmission Power Train Electronic Control System Diagnostic Code List
TH31-C9I, TH31-C9P, TH31-C9T, TH35-C11I, TH35-C13I, TH35-C13T, TH35-C15I and TH35-C15T Petroleum Power Train Packages and TH31-E61 and TH35-E81 Petroleum Transmissions Monitoring System Data Link
3606 and 3608 Engines Engine Barring Group
3606 and 3608 Engines Crankcase Explosion Relief Valves
3606 and 3608 Engines Rear Gear Group
3606 and 3608 Engines Circuit Breaker
2007/02/05 Potential Issues with Diodes in Alternators {1405}
14L Motor Grader Modulating Valve (Transmission Clutch) - Disassemble
14L Motor Grader Modulating Valve (Transmission Clutch) - Assemble
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Transmission, SPN 744 - FMI 3
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Transmission, SPN 744 - FMI 5
3500B Marine Propulsion Engines Walk-Around Inspection
TH55FT-E70 and TH55FT-E90 Petroleum Transmissions Relief Valve (Torque Converter Inlet) Pressure - Test
CX28, CX31 and CX35 On-Highway Transmissions Power Train Electronic Control System Transmission, SPN 744 - FMI 6
C0.5 and C0.7 Industrial Engines Engine Valve Lash - Inspect/Adjust
TH55FT-E70 and TH55FT-E90 Petroleum Transmissions Modulating Valve (Electronic Clutch Pressure Control) - Test
TH55FT-E70 and TH55FT-E90 Petroleum Transmissions Modulating Valve (Torque Converter Lockup Clutch) - Test