Fuel Injection Nozzles - Test/Exchange
Show/hide table
渗漏或溅溢到热表面或电气部件上的燃油会引起失火。 |
Show/hide table
注意 |
---|
不要让脏物进入燃油系统。 彻底清洁将要拆开的燃油系统部件的周围区域。 在拆开的燃油系统部件上安放适当的盖。 |
图 1 中的喷油器 (1) 没有回油管。 喷油器 (2) 有一条回油管。
Show/hide table
图 1 | g01110422 |
典型喷油嘴 |
喷油嘴易遭受喷孔磨损。 喷孔磨损是燃油污染的结果。 喷孔磨损会引起以下问题:
- 发动机将无法起动或起动困难。
- 发动机缺火或发动机运行无规律。
- 发动机功率不足。
- 发动机油耗变大。
- 发动机排气冒黑烟。
- 发动机温度过高。
- 发动机爆震或发动机内部振动。
喷油嘴应该清洗、检查、测试,必要时予以更换。 不要用钢丝刷清洁喷油嘴。 关于如何使用 8S-2245 喷油器清洁工具总成 ,请参阅专门说明书, SEHS7292。 请向 Caterpillar 代理商咨询如何清洗和测试喷油嘴。
Show/hide table
在运转的发动机周围工作时要小心。 热的或移动的发动机零件可能导致人身伤害。 |
Show/hide table
确保测试期间一直佩戴护目装备。 测试喷油嘴时,测试液以高压喷出喷嘴尖端的油孔。 在此压力下,测试液可能会穿透皮肤,对操作人员造成严重伤害。 一定要使喷油嘴的尖端的指向远离操作员,并深入集油器和接长筒。 |
为了确定喷油嘴的故障,必须一次一个把每个喷油嘴分隔开来检查。
- 起动发动机。
- 把每个喷油泵燃油管上的螺母拧松,一次拧松一个。 必须用一块布或类似材料来防止燃油喷洒在高温的排气部件上。 在松开下一个螺母之前,先拧紧每个螺母。
- 当燃油管上的一个螺母松开且出现下列情况时,可以辨认出有故障的喷油嘴:
- 排气中的烟雾部分消失或完全消失。
- 发动机性能不受影响。
应该把怀疑有故障的喷油嘴拆下来。 应该把一个新的喷油嘴装入气缸,以确定拆下来的喷油嘴是否有故障。
- 排气中的烟雾部分消失或完全消失。
喷油嘴的拆卸和安装
拆卸和安装喷油嘴需要专用工具。 详细资料请参阅维修手册。 请咨询本地 Caterpillar 代理商以获得帮助。
Caterpillar Information System:
D Series Excavator Monitoring System Password Change Mode
3406E, C12, C15 and C18 Marine Engines Can Not Reach Top Engine RPM
D Series Excavator Monitoring System Service Mode
C7 and C9 Marine Engines Sensors and Electrical Connectors
C27 and C32 Engines for Caterpillar Built Machines Cylinder Head - Install - C32
C9 Generator Set Engines Fuel Filter Base
2005/03/07 New Factory Password System for Caterpillar Engines {1000, 1900}
C9 Engines for Caterpillar Built Machines Fuel Filter Base - Remove and Install
UPS View User Guide Communication Connections
UPS View User Guide General Information (Getting Started)
UPS View User Guide Log On
UPS View User Guide Font Setting
3176C and 3196 Industrial Engines Air Compressor Drive Gear - Install - Two Cylinder
UPS View User Guide Log Files
C9 Engines for Caterpillar Built Machines Unit Injector - Remove
C9 Engines for Caterpillar Built Machines Unit Injector - Install
C27 and C32 Engines for Caterpillar Built Machines Engine Oil Pan - Remove and Install
UPS View User Guide Remote Notification
C7 and C9 Marine Engines Analog Sensor Supply Circuit - Test
2005/03/07 Improved Alternator Adjusting Rod {1405}
UPS View User Guide User Operations
UPS View User Guide Hotkeys
2005/05/23 New Hoses for the Jacket Water Heater {1383}
C7 and C9 Marine Engines CAN Data Link Circuit - Test