Fuel Filter and Base - Remove and Install - Secondary
拆卸步骤
Show/hide table
所需工具     | |||
---|---|---|---|
工具     | 零件号     | 零件说明     | 数量     |
A     | 185-3630     | 皮带扳手组件     | 1     |
注: 清洁度是一项重要的因素。 拆解步骤开始之前,应彻底清洁部件外部。 这将有助于防止污垢进入部件的内部。
注: 为便于安装,在所有管路、软管、导线和管子上做出识别标记。 塞住所有管路、软管和管子。 这将有助于防止液体泄漏和防止污染物进入系统。
Show/hide table
注意 |
---|
在检验、保养、测试、调整及维修发动机时,请小心确保盛接流出的液体。 在打开或拆解任何储有液体的部件之前,要准备好合适的容器收集液体。 有关适合收集和盛接卡特彼勒产品上的液体的工具和供应品,请参阅专门出版物, NENG2500, "卡特彼勒代理商工具目录"。 按照本地法规和条例处置所有液体。 |
- 卸下螺栓 (1) 和面板 (2) 。
Show/hide table
图 1 | g01206134 |
- 关闭燃油切断阀 (3)
Show/hide table
图 2 | g01206135 |
- 打开门 (4) 。
Show/hide table
图 3 | g01206136 |
- 断开线束组件 (5) 、 (6) 和 (7) 。
Show/hide table
图 4 | g01206138 |
- 断开软管组件 (9) 。
Show/hide table
图 5 | g01206139 |
- 使用工具 (A) 拆下燃油滤清器 (11) 。
- 拆下螺栓 (8) 和燃油滤清器座 (10) 。
安装步骤
注: 清洁度是一项重要的因素。 组装之前,应使用清洗剂彻底清洁所有零件。 让零件风干。 不要使用抹布擦干零件。 棉绒可能会留在零件上,可能导致以后出现故障。 检查所有零件。 如果任何零件磨损或损坏,则应使用新零件进行更换。
- 安装滤清器座 (10) 和螺栓 (8) 。
Show/hide table
图 6 | g01206139 |
- 安装燃油滤清器 (11) 。
- 连接软管组件 (9) 。
- 连接线束组件 (5) 、 (6) 和 (7) 。
Show/hide table
图 7 | g01206138 |
- 关闭门 (4) 。
Show/hide table
图 8 | g01206136 |
- 打开燃油切断阀 (3) 。
Show/hide table
图 9 | g01206135 |
- 安装面板 (2) 和螺栓 (1) 。
Show/hide table
图 10 | g01206134 |
Caterpillar Information System:
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Ether Start Valve - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Engine Electronic Control - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Electric Starting Motor - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Battery - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Alternator - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Air Cleaner - Remove and Install
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Electronic Control Module (Machine)
324D, 325D, 326D and 329D Excavators and 329D MHPU Mobile Hydraulic Power Unit Machine Systems Manual Valve (Auxiliary Shutoff) - Remove
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Refrigerant Compressor - Remove and Install
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Diagnostic Operation
324D, 325D, 326D and 329D Excavators and 329D MHPU Mobile Hydraulic Power Unit Machine Systems Relief Valve (Pilot) - Install
320D and 323D Excavators Hydraulic System Cylinder Speed - Check
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Muffler - Remove and Install
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Switches
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Refrigerant Condenser - Remove and Install
330D, 336D, 336D2, 340D and 340D2 Excavators and 336D MHPU Mobile Hydraulic Power Unit C9 Engine Supplement Refrigerant Receiver-Dryer - Remove and Install
345C MHPU Mobile Hydraulic Power Unit Machine Systems Pilot Valve (Travel) - Disassemble
C15 and C18 Engines for Caterpillar Built Machines Alternator Mounting
374D and 390D Excavators Machine Electronic Control System Pedal Control
416E Backhoe Loader Extendable Stick Pads - Inspect/Adjust - If Equipped
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Sensors
324D, 325D, 326D and 329D Excavators and 329D MHPU Mobile Hydraulic Power Unit Machine Systems Manual Valve (Auxiliary Shutoff) - Install
320D, 321D, 323D, 324D, 325D, 326D, 328D, 329D, 330D, 336D, 336D2, 340D and 340D2 Excavators, 324D Forest Machine and 323D MHPU, 324D MHPU, 325D MHPU, 329D MHPU, 330D MHPU and 336D MHPU Mobile Hydraulic Power Units Machine Electronic Control System Solenoids
320D and 323D Excavators Hydraulic System Engine Performance - Test - Engine Speed