Cooling System Coolant Level - Check
Show/hide table
Pressurized system: Hot coolant can cause serious burn. To open cap, stop engine, wait until radiator is cool. Then loosen cap slowly to relieve the pressure. |
- Open the engine access door.
Show/hide table
Illustration 1 g00679346 - Maintain the coolant level between the "FULL" mark (2) on the coolant reservoir and the "LOW" mark (3) on the coolant reservoir.
Note: Refer to Operation and Maintenance Manual, "General Hazard Information" for information on Containing Fluid Spillage.
- If additional coolant is necessary, remove the coolant filler cap (1) and add the appropriate coolant mixture. Install the filler cap.
Show/hide table
Illustration 2 g00374857 - If the coolant reservoir is empty, remove the cooling system pressure cap slowly in order to relieve pressure. Add coolant to the radiator.
Show/hide table
Illustration 3 g00102170 - Inspect the condition of the cap gasket. If necessary, replace the cap.
- Install the cooling system pressure cap.
- Close the engine access door.
Caterpillar Information System:
3054 Engine Lubrication System
5130B Excavator Hydraulic System Stick Cylinder (Front Shovel)
345B Excavator Hydraulic System Pressure Specifications
5130 Excavator Hydraulic System Stick Cylinder (Front Shovel)
303.5 Mini Hydraulic Excavator Bucket Tips - Inspect/Replace
345B Series II Excavator Plate Locations and Film Locations
3054 Engine Cooling System
301.5, 301.6 and 301.8 Mini Hydraulic Excavators Blade Linkage - Lubricate
M312, M315, M318 and M320 Excavators Air Conditioning and Heating Air Conditioning System
M312, M315, M318 and M320 Excavators Air Conditioning and Heating Heater System (Cab)
3306C Engines for Caterpillar Built Machines Turbocharger
301.5, 301.6 and 301.8 Mini Hydraulic Excavators Fuel Tank Cap and Strainer - Clean
5130 Excavator Hydraulic System Bucket Cylinder (Front Shovel)
5130B Excavator Hydraulic System Bucket Cylinder (Front Shovel)
301.5, 301.6 and 301.8 Mini Hydraulic Excavators Light Switches - If Equipped
5130B Excavator Hydraulic System Bottom Dump Cylinder (Front Shovel)
5130B Excavator Hydraulic System Boom Cylinder (Mass Excavator)
5130 Excavator Hydraulic System Stick Cylinder (Mass Excavator)
5130B Excavator Hydraulic System Bucket Cylinder (Mass Excavator)
M318 Excavator Hydraulic System Specifications
301.5, 301.6 and 301.8 Mini Hydraulic Excavators Lifting and Tying Down the Machine
5130 Excavator Hydraulic System Pilot Valve (Implement)
345B Excavator Hydraulic System Relief Valve (Main) - Test and Adjust
345B Excavator Hydraulic System Pilot Hydraulic System