Battery Problem
可能原因
- 蓄电池
- 开关蓄电池电路
建议的措施
在执行任何故障排除或清除诊断故障代码前，从发动机 ECM 下载产品状态报告。 在继续执行本步骤之前，诊断并排除所有现行代码。
Show/hide table
| 故障诊断与排除测试步骤 | 数值 | 结果 |
|---|---|---|
1. 检查蓄电池 A. 确认蓄电池已无法保持电量。 请参阅系统操作/测试和调整, "蓄电池 - 测试"。 |
蓄电池 |
结果：蓄电池正常。 转至测试步骤 2。 结果：蓄电池不正常。 修理：更换蓄电池。 参考拆解和装配以了解正确步骤。 |
2. 检查开关蓄电池电路 A. 确认处于接通位置时开关蓄电池电路放电。 |
开关蓄电池电路 |
结果：处于接通位置时开关蓄电池电路使蓄电池放电。 修理：为蓄电池充电。 确认蓄电池能够保持电量。 参考系统操作/测试和调整以了解正确步骤。 |
Caterpillar Information System:
C15 and C18 Engines for Caterpillar Built Machines Alternator Problem
C15 and C18 Engines for Caterpillar Built Machines Symptom Troubleshooting
C15 and C18 Engines for Caterpillar Built Machines Electrical Connectors
C15 and C18 Engines for Caterpillar Built Machines Configuration Parameters
C15 and C18 Engines for Caterpillar Built Machines Factory Passwords
193-4125 Rear Wheel Bearing Preload Adjuster for 797 Off-Highway Trucks{0374, 0599, 0700, 0722, 0727, 0730, 4008} 193-4125 Rear Wheel Bearing Preload Adjuster for 797 Off-Highway Trucks{0374, 0599, 0700, 0722, 0727, 0730, 4008}
980M and 982M Wheel Loader TA2 Technical Inspection {0372, 1000, 7000, 753T, 7565} 980M and 982M Wheel Loader TA2 Technical Inspection {0372, 1000, 7000, 753T, 7565}
966M and 972M Wheel Loader TA2 Technical Inspection {0372, 1000, 7000, 753T, 7565} 966M and 972M Wheel Loader TA2 Technical Inspection {0372, 1000, 7000, 753T, 7565}
950M and 962M Wheel Loader TA2 Technical Inspection {0372, 1000, 7000, 753T, 7565} 950M and 962M Wheel Loader TA2 Technical Inspection {0372, 1000, 7000, 753T, 7565}
C15 and C18 Engines for Caterpillar Built Machines Programmable Parameters
C13 and C15 Generator Sets Generator Start-up Checklist
CB22B, CB24B, CB32B and CC24B Utility Compactors Battery Disconnect Switch - If Equipped
C15 and C18 Engines for Caterpillar Built Machines Engine Top Speed Is Not Obtained
559C and 579C Knuckleboom Loaders Fuel Filter (In-Line) - Replace
C15 and C18 Engines for Caterpillar Built Machines Coolant Contains Oil
586C LRC Site Prep Tractor Fuel System Primary Filter (Water Separator) Element - Replace
C15 and C18 Engines for Caterpillar Built Machines Coolant Contains Fuel
586C LRC Site Prep Tractor Fuel System Secondary Filter - Replace
C15 and C18 Engines for Caterpillar Built Machines Coolant Temperature Is High
C15 and C18 Engines for Caterpillar Built Machines ECM Will Not Accept Factory Passwords
2013/09/26 Improved Caterpillar Remanufactured Fuel Injectors for Certain C7 and C9 Machine Engines {1251, 1290}
773E and 777D Off-Highway Truck/Tractor Object Detection System (Two Cameras) Object Detection Sensor - Clean/Inspect
773E and 777D Off-Highway Truck/Tractor Object Detection System (Two Cameras) Display - Clean
773E and 777D Off-Highway Truck/Tractor Object Detection System (Two Cameras) Camera - Clean