Flywheel Housing
Show/hide table
图 1 | g00751947 |
典型示例 |
注: 在装配过程中,检查下列部件上有无任何异物:飞轮壳的前端面、飞轮壳垫片的两侧和缸体的后端面。 这些部件上必须没有以下物质:机油、燃油、水、垫片粘合剂、装配固定胶和任何其他异物。 将 Loctite 587 蓝色 RTV 有机硅涂覆到缸体、飞轮壳和油底壳之间的空隙。 安装油底壳密封垫和油底壳。
(1)拧紧螺栓,如下所示:
- 将垫圈安装到螺栓上,然后按照数字顺序,拧紧螺栓 1 至 9。
九个螺栓的扭矩 ...
100 ± 20 N·m (75 ± 15 lb ft) - 将垫圈安装到螺栓上,然后按照数字顺序,拧紧螺栓 10 至 14。
五条螺栓的扭矩 ...
40 ± 10 N·m (30 ± 7 lb ft) - 将垫圈和隔套安装到螺栓上,然后按照数字顺序,拧紧螺栓 15 至 24。
十根螺栓的扭矩 ...
40 ± 10 N·m (30 ± 7 lb ft) - 按照数字顺序,一次一个,拆下螺栓 1 至 9。 装配前,在螺栓的螺纹上涂抹 Loctite 7649,然后涂抹 Loctite 263。
螺栓的扭矩 ...
135 ± 20 N·m (100 ± 15 lb ft) - 按照数字顺序,一次一个,拆下螺栓 10 至 24。 装配前,在螺栓的螺纹上涂抹 Loctite 7649,然后涂抹 Loctite 263。
15 颗螺栓的扭矩 ...
55 ± 10 N·m (40 ± 7 lb ft)
Caterpillar Information System:
C15 and C18 Engines for Caterpillar Built Machines Fan Drive
267B, 277B and 287B Multi Terrain Loaders Power Train Track Drive - Assemble
247B2 and 257B2 Multi Terrain Loaders Machine Systems Hydrostatic System - Flush and Fill
C15 and C18 Generator Set Engines Electronic Unit Injector - Remove
PS-150C Pneumatic Compactor Machine System Hydraulic Oil Filter
2006/01/02 Relocation of the Fuel Transfer Pump is Recommended for Certain Applications. {1256}
14H and 16H Motor Graders Hydraulic and Steering System Hydraulic and Steering System
216B, 226B, 232B and 242B Skid Steer Loaders Machine Systems Hydrostatic System - Test and Adjust
3406E, C-10, C-12, C-15, C-16 Truck Engines Product Storage
216B, 216B2, 226B, 226B2, 232B, 232B2, 242B and 242B2 Skid Steer Loaders Engine Supplement Fuel Priming Pump and Primary Filter (Water Separator) - Remove and Install
2004/03/22 Special Instruction, REHS1837 , "Bench Test Procedure for Bosch Rexroth A6VM HD Motors" Is Now Available {5058}
2004/03/22 Corrections to Special Instruction, REHS1738, "Installing the "B Series" Cab Door Kits" {7308}
AP-655C and BG-2255C Asphalt Pavers Machine Systems Steering Column - Remove
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Steering Column - Disassemble
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Steering Column - Assemble
AP-655C and BG-2255C Asphalt Pavers Machine Systems Steering Column - Install
770 and 772 Off-Highway Truck Engine Lockout Control
R1300G Load Haul Dump Remote Control System General Information
R1300G Load Haul Dump 3306 Engine Supplement Transmission Oil Cooler - Remove
R1600G Load Haul Dump Remote Control System System Schematic
2004/03/22 Special Instruction, REHS1799, "Installing the 233-5873 Installation Arrangement (AIR CONDITIONER, HEATER) (KIT)" Is Available {7304, 7320}
AP-655C and BG-2255C Asphalt Pavers Machine Systems Fuel Pump (Screed Burner) - Remove - CDG1-Up
AP-655C and BG-2255C Asphalt Pavers Machine Systems Fuel Pump (Screed Burner) - Install - CDG1-Up
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Fuel Pump (Screed Burner) - Disassemble