Change Oil In Any Flexxaire Fan With Serial Number Below 3000 Or JS3000 Caterpillar


Change Oil In Any Flexxaire Fan With Serial Number Below 3000 Or JS3000

Usage:

GENERALCATERPILLAR MACHINES EQUIPPED WITH FLEXXAIRE FAN

Problem:

Flexxaire fans with serial numbers below 3000 or JS3000 were filled with the incorrect oil at manufacture.

Solution:

Check the serial number plate located on the actuator support arm. If the oil must be changed, refer to the machine service manual or the manual supplied with the fan and drain the current oil (Dexron Automatic Transmission Fluid) from the fan. Fill the empty fan with Castrol FSX 5W-50 oil. Alternative oils and change intervals are as follows.

COPYRIGHT 1996 CATERPILLAR ALL RIGHTS RESERVED

Caterpillar Information System:

Regulate Oil Flow For Supplier Attachments Regulate Oil Flow For Supplier Attachments
Water Leaks Into Cab Through The Roof Seal Water Leaks Into Cab Through The Roof Seal
Loss Of Modulation May Occur On Some Motor Graders Loss Of Modulation May Occur On Some Motor Graders
Air Filter Precleaner Modification Can Increase Filter Element Life Air Filter Precleaner Modification Can Increase Filter Element Life
Drain Holes May Be Missing On Left Hand Side (LHS) Bumper Tool Box Drain Holes May Be Missing On Left Hand Side (LHS) Bumper Tool Box
Aftercooler Core Cracks Aftercooler Core Cracks
Rear Propel Pump Interlock Solenoid Wires May Break Rear Propel Pump Interlock Solenoid Wires May Break
Contact For Ordering FT-Drawings Contact For Ordering FT-Drawings
Nuts Holding The Weight Group To The Compactor Drum May Not Be Sufficiently Tight Nuts Holding The Weight Group To The Compactor Drum May Not Be Sufficiently Tight
Trims May Loosen On The Rear Of The 820G And 980G Cabs Trims May Loosen On The Rear Of The 820G And 980G Cabs
Limiting Hydraulic Oil Flow When Using Auxiliary Valves Limiting Hydraulic Oil Flow When Using Auxiliary Valves
Idler/Bogie Roller Bearings May Not Be Correct Idler/Bogie Roller Bearings May Not Be Correct
New Design Of The Rear View Mirror Support Has Been Released For The FII-Cab Of Medium Wheel Loaders New Design Of The Rear View Mirror Support Has Been Released For The FII-Cab Of Medium Wheel Loaders
Automatic Transmission Fluid (ATF) Is Not An Acceptable Lubricant For Flexxaire Fans With Serial Numbers Below 3000 Or JS3000 Automatic Transmission Fluid (ATF) Is Not An Acceptable Lubricant For Flexxaire Fans With Serial Numbers Below 3000 Or JS3000
Unused Electrical Harness Wires Need To Be Covered Unused Electrical Harness Wires Need To Be Covered
Technical Support Available For Paint Defects In Aurora Built Machines Technical Support Available For Paint Defects In Aurora Built Machines
Corrected Information Provided For 7J-5311 Warning Plate On Certain Medium Wheel Loaders And Integrated Toolcarriers Equipped With Ride Control Corrected Information Provided For 7J-5311 Warning Plate On Certain Medium Wheel Loaders And Integrated Toolcarriers Equipped With Ride Control
Casting Irregularities In Some 105-8698 Axle Housings And 105-8699 Axle Housings May Allow Oil Seepage In Certain Areas Of The Axle Housing Casting Irregularities In Some 105-8698 Axle Housings And 105-8699 Axle Housings May Allow Oil Seepage In Certain Areas Of The Axle Housing
Special Care Necessary For Proper Alignment Of Brake Pumps During Pump Group Disassembly And Assembly Special Care Necessary For Proper Alignment Of Brake Pumps During Pump Group Disassembly And Assembly
Compatibility Problem With Challenger Technician (CT) When Setting Mode 12 Features With EMC Software V6.37 Compatibility Problem With Challenger Technician (CT) When Setting Mode 12 Features With EMC Software V6.37
Procedure To Reduce Contamination Of Telehandler Hydraulic Tanks Procedure To Reduce Contamination Of Telehandler Hydraulic Tanks
Additional Holes In Cylinder Head Gasket Additional Holes In Cylinder Head Gasket
Product Support Organization For Caterpillar Belgium Medium Wheel Loaders Product Support Organization For Caterpillar Belgium Medium Wheel Loaders
Installation Of Oil Distributor Sleeves in Telehandler Transmissions Installation Of Oil Distributor Sleeves in Telehandler Transmissions
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.