DEF Tank Level Is High
Use this procedure to troubleshoot a high Diesel Exhaust Fluid (DEF) tank level. Also, use this procedure if the following event code is active or logged.
Show/hide table
| J1939 Code and Description | CDL Code and Description | Comments |
|---|---|---|
| 1761-15
Aftertreatment #1 DEF Tank Volume : High - least severe (1) |
E1983 (1)
Aftertreatment #1 DEF Dosing Unit Input Lines Not Purged |
The Diesel Exhaust Fluid (DEF) system has failed to purge. |
Show/hide table
| |
| Illustration 1 | g03738409 |
|
(1) Remote tank
(2) DEF tank refill valve (3) Buffer tank (4) DEF transfer pump (optional) (5) DEF filter | |
- DEF level
- Codes
Show/hide table
| Troubleshooting Test Steps | Values | Results |
|---|---|---|
1. Check the Remote DEF Tank Level A. Visually inspect the DEF level in the Remote DEF tank. |
DEF Level |
Result: The remote DEF tank level is above the high DEF level switch. Repair: Remove DEF from the remote DEF tank. Return to service. Result: The remote DEF Tank level is not above the high DEF level switch. Repair: Replace the high DEF level switch in the remote tank. Proceed to Test Step 2. |
2. Check for Codes A. Turn the DC breaker to the ON position. B. Connect Cat® Electronic Technician (ET) to the service tool connector. C. Determine if a code is active or logged. |
Codes |
Result: A E1983 or 1761-15 code is logged. Return to service. Result: A E1983 or 1761-15 code is active. Repair: There is a short to ground in the wiring harness between the remote DEF tank level switch and the Selective Catalyst Reduction (SCR) controller. Repair or replace the wiring harness. Verify that the repair eliminated the problem. |
If the procedure did not correct the issue, contact your Cat dealer Technical Communicator (TC). For further assistance, your TC can confer with the Dealer Solutions Network (DSN).
Caterpillar Information System:
Selective Catalytic Reduction Retrofit Aftertreatment DEF Pressure Is Low
Selective Catalytic Reduction Retrofit Aftertreatment DEF Pressure Is High
Selective Catalytic Reduction Retrofit Aftertreatment DEF Does Not Purge
Selective Catalytic Reduction Retrofit Aftertreatment Clean Emissions Module Has High Oxygen Level
Selective Catalytic Reduction Retrofit Aftertreatment Air Assist Pressure Is Low
Selective Catalytic Reduction Retrofit Aftertreatment Air Assist Pressure Is High
C175 Tier 4 Final Engines for Off-Highway Trucks DEF Controller Resistor - Test
793F Off-Highway Truck Exhaust Outlet Nitrogen Oxide Sensor - Replace
793F Off-Highway Truck Exhaust Inlet Nitrogen Oxide Sensor - Replace
390F Excavator Product Identification Number
793F Off-Highway Truck Selective Catalytic Reduction Warning System
New Fuel Line Mounting Hardware is Now Used on Certain C9 On-Highway Truck Engines {1274} New Fuel Line Mounting Hardware is Now Used on Certain C9 On-Highway Truck Engines {1274}
Selective Catalytic Reduction Retrofit Aftertreatment DEF Tank Level Is Low
Selective Catalytic Reduction Retrofit Aftertreatment DEF Tank Temperature Is High
Selective Catalytic Reduction Retrofit Aftertreatment DEF Tank Temperature Is Low
Selective Catalytic Reduction Retrofit Aftertreatment NOx Conversion Is Low
Selective Catalytic Reduction Retrofit Aftertreatment SCR Catalyst Inlet Pressure Is High
Selective Catalytic Reduction Retrofit Aftertreatment SCR Catalyst Inlet Pressure Is Low
Selective Catalytic Reduction Retrofit Aftertreatment Data Link - Test
Selective Catalytic Reduction Retrofit Aftertreatment DEF Pump Motor - Test
Selective Catalytic Reduction Retrofit Aftertreatment Sensor Signal (Analog, Active) - Test
Selective Catalytic Reduction Retrofit Aftertreatment System Overview
Selective Catalytic Reduction Retrofit Aftertreatment Diagnostic Trouble Codes
C4.4 Generator Sets Air Inlet and Exhaust System