Welding Precaution
为避免损坏电子控制模块(ECM)、传感器和相关部件,必须采用的焊接步骤。 用于从动设备的部件也应考虑。 按照下述步骤对发动机进行焊接。
- 将发动机控制置于"停机"模式。
- 确保关断通往发动机的燃气供给。
- 断开蓄电池上的负极接线端。
- 断开接线线束上的所有电气部件。 断开下列部件:
- 从动设备的电气部件
- 发动机电子控制模块
- 燃油执行器
- 传感器
- 油门执行器
- 从动设备的电气部件
- 可能时,将接地卡箍直接连接到将要焊接的发动机部件上。 将卡箍尽可能靠近焊接点,以降低焊接电流损坏以下部件的可能性:
- 发动机轴承
- 电气部件
- 其它发动机部件
- 发动机轴承
Show/hide table
注意 |
---|
切勿将电气零部件(ECM电子控制模块或电子控制模块传感器) 或电子零部件的接地点用作焊接机的接地点。 |
- 保护接线线束远离焊接碎屑和溅渣。
- 使用标准的焊接步骤。
Caterpillar Information System:
G3304B and G3306B Engines Valve Lifter - Remove
2009/07/27 Improved Procedure for the Retention of the Identification Film for the Roll Over Protective Structure (ROPS) and Falling Object Protective Structure (FOPS) {7323, 7325, 7405, 7557}
G3304B and G3306B Engines Rocker Shaft - Assemble
797F and 797F XQ Off-Highway Truck Power Train Oil Filter (Final Drive)
C13, C15, and C18 Tier 4 Interim Engines Injector Solenoid - Test
797F and 797F XQ Off-Highway Truck Hydraulic System Hydraulic Tank (Brake, Hoist, Steering) - Extra Retarding
C13 Tier 4 Final Engines Valve Rocker Arm
C18 Power Module Setup
G3304B and G3306B Engines Rocker Shaft - Disassemble
C18 Power Module Before Starting Engine
C9.3 Tier 4 Final Engines Diesel Particulate Filter Has High Ash Load
C9.3 Engines for Caterpillar Built Machines Fumes Disposal Filter - Remove and Install
G3304B and G3306B Engines Valve Lifter - Install
G3304B and G3306B Engines Troubleshooting Data Sheet
793F and 797F Off-Highway Trucks Power Train Electronic Control System Using Caterpillar Electronic Technician to Determine Diagnostic Codes
793F CMD Off-Highway Truck (Command for Hauling) Power Train Electronic Control System Engagement Pressure for the Transmission Clutch - Calibrate
793F CMD Off-Highway Truck (Command for Hauling) Power Train Electronic Control System Fill Time for the Transmission Clutch - Calibrate
G3304B and G3306B Engines Inlet and Exhaust Valves - Remove and Install
797F and 797F XQ Off-Highway Truck Power Train Gear Pump (Brake, Rear Axle Lubrication) - Extra Retarding
797F and 797F XQ Off-Highway Truck Braking System Motor Rotating (Brake Cooling) - Extra Retarding
797F and 797F XQ Off-Highway Truck Braking System Piston Pump (Brake Cooling) - Extra Retarding
CD44B and CD54B Vibratory Asphalt Compactors Alternator - Inspect
2009/08/03 Pistons and Piston Rings {1225, 1225}
G3304B and G3306B Engines Inlet and Exhaust Valve Guides - Remove and Install