2008/11/01 Caterpillar


Policy on Testing of Fuel Injectors and Fuel Nozzles {1251}

Usage:

769C 01X
Caterpillar Products:
  • All
  • Do not use any off-engine diagnostic test on fuel injectors or fuel nozzles prior to installation of the injectors or nozzles. Caterpillar Fuel Systems Division does not recommend the use of any test equipment that is outside of the factory for field evaluation of injectors and nozzles prior to the installation of the injectors or nozzles.

    The Marketing and Product Support Division supports the recommendation of the Fuel Systems Division.

    Fuel Injectors

    • The 6V-4022 Fuel Injector Tester was cancelled and replaced by components that were also cancelled or discontinued.

    • The 1U-6661 Pop Tester Gp was discontinued.

    The testers were rendered obsolete by increased injection pressures and by performance requirements for injectors. The inaccuracy of the testers' use with improved injectors resulted in replacement of good injectors. This caused warranty claims for injectors with no fault.

    The service literature that was related to the testers has been removed from the Service Information System (SIS) and from Media Logistics. References to the testers and to the removed service literature have also been removed or the references are in the process of being removed.

    The Marketing and Product Support Division will no longer accept any warranty claims on any injectors that are evaluated by the above testers or by any other commercial device that is used for the testing of injectors.

    Fuel Nozzles

    The 5P-4150 Nozzle Testing Group is used for the bench testing of fuel nozzles only after the nozzles have been tested in the engine and the performance of the nozzles are questionable.

    The 5P-4150 Nozzle Testing Group is still serviceable.

    Do not use the 5P-4150 Nozzle Testing Group with fuel injectors.

    The Marketing and Product Support Division will no longer accept any warranty claims on any nozzles that are evaluated prior to being tested by engine operation.

    Caterpillar Information System:

    2008/11/17 Policy on Testing of Fuel Injectors and Fuel Nozzles {1251}
    2008/11/17 Policy on Testing of Fuel Injectors and Fuel Nozzles {1251}
    2008/12/01 New Primary Fuel Filter {1258, 1261, 1263}
    G3500B Engines Diagnostic Trouble Codes
    345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Gear Pump (Pilot) - Install
    345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Gear Pump (Pilot) - Remove
    G3500B Engines Troubleshooting Data Sheet
    C6.6 Marine Generator Set EMCP3 General Information
    C6.6 Marine Generator Set Jacket Water Heater - Remove and Install
    345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Fan Pump - Install
    345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Fan Pump - Remove
    2008/11/10 A New Heat Shield for the Exhaust Manifold is Available {1067}
    345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Main Hydraulic Pump and Pump Drive Coupling - Remove
    345D, 349D and 349D2 Excavators and 345D MHPU and 349D MHPU Mobile Hydraulic Power Units Machine Systems Main Hydraulic Pump and Pump Drive Coupling - Install
    G3500B Engines Configuration Parameters
    G3500B Engines Camshaft
    793F and 797F Off-Highway Trucks Chassis Electronic Control System System Schematic
    2008/12/01 Water Temperature Regulator {1355, 1380}
    G3520C and G3520E Generator Set Engines Vibration Damper - Disassemble
    2008/11/17 Do Not Use the 6V-4022 Fuel Injector Tester to Measure Unit Injector Fuel Flow Rate {1251, 1254, 1290, 1713}
    G3520C and G3520E Generator Set Engines Vibration Damper - Assemble
    G3520C and G3520E Generator Set Engines Vibration Damper - Remove
    2008/11/17 The 6V-4022 Fuel Injector Tester Is not Available {1251, 1254, 1290, 1713}
    TH48-E70 Petroleum Transmission and TH48-E70-C27I, TH48-E70-C32I and TH48-E70-C32P Petroleum Power Train Packages Speed Sensor (Transmission) - Engine Output
    Back to top
    The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
    CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.