2008/05/19 Caterpillar


A New Version of Caterpillar Electronic Technician (ET) is Now Available {0785, 7600, 7610}

Usage:

769C 01X
Agricultural Tractor:
85D DS MTS (S/N: 6AR1-UP)
MT855 MTS (S/N: A3A1-UP)
MT865 MTS (S/N: GDA1-UP)
Combine:
Lexion 450 COMBINE HARVESTER (S/N: 5GG1-UP)
Lexion 470 R COMBINE HARVESTER (S/N: 4ZF1-UP)
Lexion 480 COMBINE HARVESTER (S/N: 7ZR1-UP)
Lexion 480 R COMBINE HARVESTER (S/N: JAC1-UP)
Soil Compactor:
825C (S/N: BKN1-UP)
Excavator:
315C L (S/N: CRX1-UP)
325D L (S/N: C7C1-UP)
325D (S/N: KHX1-UP)
330D L (S/N: THX1-UP; THY1-UP)
345C (S/N: MHX1-UP)
365C L (S/N: LHX1-UP)
385B (S/N: BLC1-UP)
385C (S/N: RHX1-UP)
Track Feller Buncher:
TK1051 (S/N: 3PD1-UP)
Load Haul Dump:
R2900 (S/N: 9AP1-UP)
Off-Highway Truck/Tractor:
773D (S/N: 1KR1-UP)
773F (S/N: EHX1-UP)
777F (S/N: LJW1-UP)
785 (S/N: 8BR1-UP)
797 (S/N: 3TN1-UP; 2CS1-UP; 1AW1-UP)
Quarry Truck:
775F (S/N: LJX1-UP)
Track-Type Tractor:
D10N (S/N: 5JJ1-UP)
D10R (S/N: 80M1-UP)
D5N PS XL FTC (S/N: BMA1-UP)
D6RSeries II STD FTC (S/N: SAN1-UP)
D8L PS (S/N: 5XD1-UP)
D8N (S/N: BET1-UP)
D9R (S/N: 99C1-UP)
Wheel Loader:
928G (S/N: CPT1-UP)
950GSeries II (S/N: CSW1-UP)
966H (S/N: RSX1-UP)
972GSeries II (S/N: 5ED1-UP)
988B (S/N: 48W1-UP)
992G (S/N: 2GR1-UP)

A new version of Caterpillar Electronic Technician (ET) is now available. The new version of Cat (ET) will support the updates to the factory password system. The changes to the factory password system will start in the fourth quarter of 2008.

The changes for the factory password system are listed below.

  • No passwords will be available for service tool versions prior to Cat (ET) 2005B.

  • Cat (ET) 2005B and later can be used to obtain factory passwords with reason codes that do not involve emissions or regulatory compliance. Cat (ET) version 2008A and later must be used to obtain factory passwords with reason codes for emissions and regulatory compliance. Table 1 shows the Reason Codes.

Make sure to update all service tool personal computers to version 2008A or later in order to avoid any complications with the restrictions that will take affect in the fourth quarter of 2008.

Table 1
Description for the Reason Codes    
1     Modify Factory Settings for Full Load Setting (FLS), and Full Torque Setting (FTS)    
5     Engine Rerate    
10     Perkins Engine Rerate    
66     Transmission Output Revolutions Configuration    
67     Ash Service Diesel Particulate Filter (DPF) # 1    
68     Ash Service DPF # 2    
120     Aftertreatment Regeneration Device Configuration    
122     DPF Serial Number Configuration    
126     Top Ground Speed    
127     Memory Read Security    
128     Engine Emissions Certification Configuration    
136     FLS    
145     Engine Brake System Installation    

Caterpillar Information System:

C7 PETROLEUM Petroleum Engine Air Lines - Remove and Install
C175-16 Locomotive Engines Fuel System Primary Filter/Water Separator - Drain
New Engine Software May Cause a Diagnostic Code{1901, 7620} New Engine Software May Cause a Diagnostic Code{1901, 7620}
Troubleshooting Turbochargers on the 2007 Model Year C13 and C15 On-highway Engines{1000, 1050, 1052, 1053} Troubleshooting Turbochargers on the 2007 Model Year C13 and C15 On-highway Engines{1000, 1050, 1052, 1053}
345D, 349D and 349D2 Excavators Hydraulic System Control Valve (Straight Travel)
345D, 349D and 349D2 Excavators Hydraulic System Oil Makeup (Travel System)
345D, 349D and 349D2 Excavators Hydraulic System Travel Counterbalance Valve
C175 Generator Sets Fuel System Primary Filter - Clean/Inspect/Replace
345D, 349D and 349D2 Excavators Hydraulic System Pilot Valve (Travel)
3176C, 3406E and 3456 Industrial Engines Sensor Signal (PWM) - Test
C175-16 and C175-20 Generator Set Engines Flywheel Housing
3500B Engines and 776D, 777D, 784C, 785C, 789C, 793C and 793D Off-Highway Truck/Tractors Crankcase Breather
2008/05/26 A New Version of Caterpillar Electronic Technician (ET) is Now Available {0785, 1900, 7610}
2008/05/01 A New Version of Caterpillar Electronic Technician (ET) is Now Available {0785, 1900, 7610}
C175-16 and C175-20 Generator Set Engines Engine Does Not Crank
CX28 On-Highway Transmission Output Transfer Yoke
C15 Industrial Engines Configuration Parameters
2008/03/03 A New Oil Filter Group is Now Used on the TH48-E80 Oil/Gas Transmission {3030, 3067}
C7 PETROLEUM Petroleum Engine Aftercooler - Remove
C175-16 and C175-20 Generator Set Engines Engine Overspeeds
C175-16 and C175-20 Generator Set Engines Fuel Filter Is Restricted
C7 PETROLEUM Petroleum Engine Aftercooler - Install
C175-16 and C175-20 Generator Set Engines Fuel Pressure Is Low - Fuel Supply System
C175-16 and C175-20 Generator Set Engines Inlet Air Is Restricted
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.