Fasteners
Show/hide table
图 1 | g01435679 |
(1) 组装前,表面必须清洁,没有防护涂层。
注: 将 9S-3263 螺纹固定剂 涂抹在螺栓 (2) 螺纹上。
(2) 40 个螺栓的扭矩 ... 900 ± 100 N·m (660 ± 75 lb ft)
Show/hide table
图 2 | g01435680 |
(3) 将 4C-5599 防粘合剂 涂抹到 4 个销上。
注: 将 4C-4030 螺纹锁固胶 涂抹在螺栓 (4) 的螺纹上。 再将螺栓转动 45 ± 5 度。
(4) 20 个螺栓的扭矩 ... 150 ± 30 N·m (110 ± 22 lb ft)
(5) 2 个软管卡箍的扭矩 ... 4.5 ± 0.5 N·m (40 ± 4 lb in)
Show/hide table
图 3 | g01435704 |
截面 D-D |
(6) 组装前,表面必须清洁,且没有防护涂层。
(7) 组装到机架总成前,用 1U-8846 垫片密封胶 涂抹表面。
Caterpillar Information System:
C9 Petroleum Engines Cylinder Block Cover - Remove and Install
G3600 Engines Sensor Signal (PWM) - Test
C9 Petroleum Engines Crankcase Breather - Remove and Install
C27 and C32 Engines for Caterpillar Built Machines Valve Actuator (Variable) - Install
C4.4 Generator Set Engines Injector Solenoid Circuit - Test
TH55-E70 and TH55-E90 Petroleum Transmissions Torque Converter - Assemble
TH55-E70 and TH55-E90 Petroleum Transmissions Torque Converter - Disassemble
TH55-E70 and TH55-E90 Petroleum Transmissions Torque Converter - Install
TH55-E70 and TH55-E90 Petroleum Transmissions Torque Converter - Remove
C9 Petroleum Engines Housing (Front) - Install
C15 and C18 Petroleum Generator Sets Speed Sensor - Clean/Inspect
TH55-E70 and TH55-E90 Petroleum Transmissions Transmission and Torque Converter - Connect
G3600 Engines Fuel Control - Test
320D and 323D Excavators Hydraulic System Swing Drive
C9 Petroleum Engines Rocker Arm and Shaft - Install
Inspection and Reconditioning Procedures of Main Bearing Bores in Cylinder Blocks {1201, 1202, 1224, 1224} Inspection and Reconditioning Procedures of Main Bearing Bores in Cylinder Blocks {1201, 1202, 1224, 1224}
Electronic Modular Control Panel II+ Paralleling (EMCP II+P) Troubleshooting Diagnostic Codes
2007/12/03 Improved Wiring for the Speed Control for the Electronic Governor {1408, 1417}
C9 Petroleum Engines Cylinder Head - Remove
Electronic Modular Control Panel II+ Paralleling (EMCP II+P) Display of Voltage or Current or Power Is Inaccurate
G3600 Engines Prelubrication - Test
Caterpillar Machine Fluids Recommendations Distillate Diesel Fuel
C9 Petroleum Engines Cylinder Head - Install
C175 Generator Sets After Starting Engine