777D and 777E Off-Highway Truck Air System and Brakes Caterpillar


Brake Oil Overheating Troubleshooting

Usage:

777D FKR
如果制动器系统中出现过热状况,操作员可能会通过 Caterpillar 监控系统得知过热状况。


图 1g00646019
777D 系列非公路用卡车的仪表板仪表视图
(1) "制动器油温表"
(2) "行动灯"


图 2g00646021
777D 系列非公路用卡车的控制台指示灯视图
(2) "行动灯"
(3) "报警指示灯"
(4) "信息面板"


图 3g06092710
777E 系列非公路用卡车的机器监控控制台视图
(4) "信息中心"

卡车接收来自"制动器油温"传感器的信号。 "制动器油温"传感器位于"举倾机构和制动器液压油箱"前面的"制动器冷却回流管路"上。 "制动器油温度表" (1) 显示此传感器输入。



图 4g00281171
777D 系列非公路用卡车温度读数视图
(A) 温度读数为 110°C (230°F)
(B) 温度读数为 124°C (255°F)

定期检查"制动器油温度表" (1)。 在此测试步骤期间,请勿让制动器机油温度过热。 温度超过 124°C (255°F) 可损坏制动系统。

当油温相对于当前情况过高时,警报指示器 (3) 和行动灯 (2) 会点亮。 信息区 (4) 内显示事件。 如果制动器油过热,减少机器负载或降低机器速度。 另外,将变速箱降档到较低的速度档。 为了更好的冷却,将卡车停放在便利位置。 将变速箱置于空档,让发动机以大约 1500 rpm 的转速运转。

问题:机油温度表指示高温,但没有警报指示器。

根据制动器机油温度表 (1),油温过高。 行动灯 (2) 和警报指示器 (3) 熄灭。

可能的原因

查看信息区 (4) 内显示的事件。 确定电气系统中错误的位置。 请参阅示意图, "777D 非公路卡车电气示意图"。 有关更多信息,请咨询您的 Caterpillar 代理商。

问题:油温正常,但行动灯点亮。

油温在正常范围内,但行动灯 (2) 点亮。

注: 行动灯 (2) 在油温达到 124°C (255°F) 时点亮。 行动灯保持点亮状态,直到油温降至大约 110°C (230°F)。 "行动灯"点亮时"制动器油温度表" (1) 可能显示正常油温。

可能的原因

查看信息区 (4) 的事件。 确定电气系统中错误的位置。 请参阅示意图, "777D 非公路卡车电气示意图"。 有关更多信息,请咨询您的 Caterpillar 代理商。

问题:油温过高。

根据"制动器油温度表" (1),油温过高。 "行动灯" (2) 和"警报指示器" (3) 点亮。 信息区 (4) 显示有关制动器油温的事件。

可能的原因

没有正确操作卡车。

参考: 请参考操作和维护手册以了解制动器和减速器系统的正确操作技巧。

再次运行机器。 确保发动机转速不会降到 1700 rpm 以下。 该转速确保足够的机油流经"制动器油冷却器",以将机油保持在正常工作温度。

问题:正常操作的机器上油温过高。

根据"制动器油温度表" (1),油温过高。 卡车正常操作之后,"行动灯" (2) 和"警报指示器" (3) 仍然点亮。 信息区 (4) 显示有关制动器油温的事件。

可能的原因



图 5g01346792
(5) "变矩器扫油"段
(6) "变矩器充油泵"段
(7) "停车制动器分离泵"段


图 6g01346794
(8) "制动器油冷却器安全阀"


图 7g01346795
(9) "举倾机构泵"
(10) "泵驱动装置"

  • 机油冷却系统存在阻塞。 有关空气系统和制动器,请参考测试和调整, "制动器冷却压力 - 检查",以确定是否存在正常的制动器冷却油流。

  • "变矩器充油泵"段 (6) 有故障。 请参阅测试和调整, "举倾机构、变矩器和制动器系统故障诊断与排除"中的检查步骤。

  • "举倾机构泵" (9) 有故障。 请参阅测试和调整, "举倾机构、变矩器和制动器系统故障诊断与排除"中的检查步骤。

  • "制动器油冷却器安全阀" (8) 设置过低。 请参阅液压系统测试和调整, "安全阀(制动器机油冷却器)- 测试和调整"。

Caterpillar Information System:

777D and 777E Off-Highway Truck Air System and Brakes Operational Checks
RM-300 Reclaimer Mixer Machine Systems Hydraulic Lines (Emulsion Pump)
C15 and C18 Petrolem Generator Set Engines Oil Contains Fuel
777G Off-Highway Truck Power Train Transmission Hydraulic Control - Disassemble
3126B Engine for Caterpillar Built Machines Analog Sensor Supply Circuit - Test
PL61 Pipelayer and D6K Track-Type Tractor MID 039 - CID 2211 - FMI 03
14M Motor Grader Engine Supplement Refrigerant Compressor - Remove and Install
2006/11/20 Software for Track Feller Bunchers Has Been Updated {1408, 7490, 7620}
777E, 777F and 777G Off-Highway Truck Electric Drive Pump (Prelubrication) - Remove and Install
735, 740 and 740 EJECTOR Articulated Trucks - Noise from the Power Train Is Sometimes Part of Normal Operation{3030, 3073, 3157, 3166} 735, 740 and 740 EJECTOR Articulated Trucks - Noise from the Power Train Is Sometimes Part of Normal Operation{3030, 3073, 3157, 3166}
C13 and C15 On-highway Engines Coolant Contains Oil
PL61 Pipelayer and D6K Track-Type Tractor MID 039 - CID 1933 - FMI 04
RM-300 Reclaimer Mixer Machine Systems Water and Emulsion Lines
777D and 777E Off-Highway Truck Air System and Brakes Relief Valve (Brake Oil Cooler) - Test and Adjust
450E Backhoe Loader Engine Starting with Starting Aid
3126B Engine for Caterpillar Built Machines Injection Actuation Pressure Sensor - Test
816F Series 2 Landfill Compactor, 815F Series 2 Soil Compactor and 814F Series 2 Wheel Dozer Machine Systems Front Frame from Rear Frame - Separate
R2900G Load Haul Dump Machine Systems Bucket Control Safety Pins - Remove and Install
R1700G Load Haul Dump Caterpillar Monitoring System
2014/06/03 New Water Pump, Water Temperature Regulator and Bypass Tube {1355, 1361}
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Sensors and Electrical Connectors
3054E and 3056E Industrial Engines and Engines for Caterpillar Built Machines Engine Wiring Information
773F Off-Highway Truck and 775F Quarry Truck Power Train Rear Wheel, Bearing, and Duo-Cone Seal - Remove
773F Off-Highway Truck and 775F Quarry Truck Power Train Rear Wheel, Bearing, and Duo-Cone Seal - Install
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.