UPS 120, UPS 150, UPS 250 and UPS 300 Uninterruptible Power Supplies Caterpillar


Storage

Usage:

UPS 250 APZ

UPS长期存放要求

工作温度

  • 工作范围: 0.0 °C (32.0 °F)至40.0 °C (104.0 °F)

外面存放

任何多长时间UPS都不应存放在外面。

短期存放的条件

  • 短 期存放的温度范围: −25.0 °C (−13.0 °F)到70.0 °C (158.0 °F),无冷凝下湿度 5%到95%。

这些条件覆盖了设备从工厂到代理商或从代理商到用户的时间。 UPS在这些条件下存放的总时间可为两个月。

长期存放的条件

  • 长期存放的温度范围: 0.0 °C (32.0 °F)到40.0 °C (104.0 °F), 无冷凝下湿度为5%到75%。 在下列这些条件下,UPS可以存放一年,而不需要任何附加条件。 如果UPS打算存放一年以上,下面所列的"长期存放条件"的程序应被执行。 必须保存这些步骤的记录以确保保修中覆盖的内容。

长期存放条件

每年需要进行下列内容。

  • 对系统彻底进行目测检查,检查任何零部件有无可能由于存放环境而产生有负面的影响。

  • 更换真空泵油。 真空泵最少运行四小时,以润滑内部油封。 这个程序将保证真空泵功能正常。 油对真空泵的性能很关键。 使用过的油或污染的油可能在起动时造成等待真空时间过长,或不能达到运行飞轮所需的真空度。

注: 泵被内置为在240伏下运转。 为在 UPS 通电前运行真空泵,暂时断开到泵右侧的插座插头的 240 伏内部接线。 连接外部电源的 240 伏软线 在 UPS 输入端通电前,确保已断开外部 240 伏电源,并重新连接到真空泵插座的内部240伏接线。 为 120 伏下操作的真空泵重新配置将使泵的保修无效。

注: UPS 真空泵有一个防改动 标签。 这可防止在试车过程中维修技工重新配置泵和利用交流120 V电源,进行飞轮上的真空抽吸过程。 破损的防改动标签将使与真空泵有关的保修失效。

Caterpillar Information System:

G3600 Engines Fuel Lines
G3600 Engines Fuel Lines
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Capacitor (Input/Output Cabinet)
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys 4 Wire Transformer Sensors
UPS 120, UPS 150, UPS 250 and UPS 300 Uninterruptible Power Supplies Vacuum Pump Startup - Required Procedure After Extended Storage
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Gen Set Module Circuit Breaker
3508 EUI Engine for Off-Highway Truck/Tractors Gear Group (Rear)
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys External Source Sync Terminal Block
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Storage
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys External Source Sync PWA (Input/Output Cabinet)
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Discharge Resistor
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys MOV Surge Protector
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys General Information (Static Switch Cabinet)
C175-16 Locomotive Engine Auxiliary Water Pump
3516C HD Generator Set with Gearbox Engine Rating Definitions
3126B Marine Engine Aftercooler - Disassemble
3500 Engines Camshaft
3500 Generator Sets with Dynamic Gas Blending Engine Speed/Timing Sensor - Clean/Inspect
SPF343 and SPF343C Trailer Mounted Pumpers Fuel System Primary Filter (Water Separator) Element - Replace
TA19-M2WD and TA19-M4WD Agricultural Transmissions Operational Checks
TA19-M2WD and TA19-M4WD Agricultural Transmissions General Troubleshooting Information
TA22-4WD Agricultural Transmission Pressure for Transmission Lubrication - Test
TA22-4WD Agricultural Transmission Transmission Clutch
TA19-M2WD and TA19-M4WD Agricultural Transmissions Modulating Valve
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.