Caterpillar 270 Air Compressor Caterpillar


Excessive Build-Up and Recover Time

Usage:

C13 LEE

Symptom

The buildup time and the recovery time are excessive. The air compressor will charge the vehicle air system with a volume fluctuating from 93 L (5640 cu in) to 181 L (11040 cu in)from 690 kPa (100 psi) in less than 25 seconds.

Probable Cause

  • Dirty air filter

Inspect the air filter and replace the air filter, if necessary.

  • Restricted air induction line

Inspect the air induction line for restrictions. Replace the air induction line, if necessary.

  • Restricted discharge line or discharge chamber

Inspect the discharge port of the air compressor and the discharge line of the air compressor for restrictions or carbon buildup. Check for proper cooling of the air compressor if carbon buildup is found. Replace any faulty sections of the discharge line, if necessary.

  • Slipping drive components

Check for faulty drive gears. Replace the air compressor, if necessary.

  • Excessive leakage of the air system

Test for excessive leakage of the air system. Repair air leaks, if necessary. Build the pressure in the air system until the air system reaches the pressure for the governor cutout. Allow the air system pressure to stabilize for one minute. Read the dash gauge and record the system pressure. Wait for two minutes and read the dash gauge. Record the system pressure again. Subtract the second reading from the initial reading. Divide this figure by the number of reservoirs on your vehicle and trailer. Compare this figure with the values in Table 1.

Table 1
Type of Vehicle     Pressure Drop After 2 Minutes    
Tractor without Trailer    
14 kPa (2 psi)    
Tractor and One Trailer    
41 kPa (6 psi)    
Tractor and Two Trailers    
55 kPa (8 psi)    

  • Sticking unloader piston

Check the operation of the unloading mechanism. Check the operation of the governor. Inspect the tubing and hoses that are connected to these components. Check for restrictions. If the governor operates properly, the problem is with the unloading mechanism of the air compressor.

  • Faulty air compressor

Repair the air compressor or replace the air compressor if none of the described conditions exist.

Caterpillar Information System:

Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.