Evaporator Coil and Heater Coil - Remove
拆卸步骤
开始:
- 拆卸鼓风机用马达。 请参阅拆解和组装, "鼓风机用马达(空调、加热器)- 拆卸"。
Show/hide table
接触制冷剂会使人受伤。 此系统永远处于加压状态,即便发动机没有工作也是如此。 切勿让已加注制冷剂的系统受热。 接触制冷剂会造成冻伤。 让手、脸避开有助于防止受伤。 制冷管路打开时,须始终佩带护目镜,即便压力计显示系统中已经没有制冷剂,也须佩带。 取下接头时务必小心谨慎。 慢慢地拧松接头。 如果此系统仍然有压力,请抽空系统,回收制冷剂,然后再拆下接头。 通过点燃的香烟吸入制冷剂会导致人身伤害或死亡。 通过点燃的香烟或其他抽烟方法吸入空调制冷气体,或吸入燃烧空调制冷气体形成的烟雾,都会导致人身伤害或死亡。 维修空调时,或在任何可能存在制冷气体的情况下都不要抽烟。 请先将机器移至平坦的地方,然后再对空调和加热系统进行检查。 把所有机具降到地面。 确保变速箱处于空档或停车位置,确保停车制动器接合。 让所有其他人员远离机器。 |
- 回收空调系统中的空调制冷剂。 请参阅维修手册, SENR5664, "使用 R-134a 制冷剂的空调与暖风系统",了解相关正确步骤。 请参阅专门出版物, NEDG5065, "空调工具"了解正确工具信息。
- 断开软管组件 (1) 。 卸下螺栓 (2) 。 拔出管 (3) 。 断开线束组件 (4) 。 拆卸板组件 (5) 。
Show/hide table
图 1 | g01081867 |
- 拆下螺栓 (6) 。 拆下蒸发器盘管 (7) 。
Show/hide table
图 2 | g01081875 |
- 拆下螺母 (8) 和盖 (9) 。
Show/hide table
图 3 | g01081878 |
- 断开软管 (10) 。 拆卸螺栓 (11) 和加热器芯 (12) 。
Show/hide table
图 4 | g01081882 |
Caterpillar Information System:
Installation Guide for the Machine Security System on Skid Steer Loaders and Multi Terrain Loaders{7631} Installation Guide for the Machine Security System on Skid Steer Loaders and Multi Terrain Loaders{7631}
446D Backhoe Loader Power Train Drive Shaft (Rear) - Remove and Install
797B Off-Highway Truck Engine Components - Rebuild//Replace/Install Reman - 797B LAA Machines Only
AP-800D and BG-230D Asphalt Pavers Machine Systems Gear Motor (Ventilation)
446D Backhoe Loader Power Train Drive Shaft (Front) - Remove and Install
826H Landfill Compactor, 825H Soil Compactor and 824H Wheel Dozer Engine Supplement Refrigerant Condenser - Remove and Install
826H Landfill Compactor, 825H Soil Compactor and 824H Wheel Dozer Engine Supplement Refrigerant Compressor - Remove and Install
2004/06/28 Special Publications on Multi Terrain Loader Undercarriages Are Now Available {4150}
988H Wheel Loader Machine Systems Blower Motor (Air Conditioner, Heater) - Install
446D Backhoe Loader Power Train Parking Brake - Remove and Install
988H Wheel Loader Machine Systems Blower Motor (Air Conditioner, Heater) - Remove
AP-800D and BG-230D Asphalt Pavers Machine Systems Paver Ventilation System
446D Backhoe Loader Engine Supplement Fuel Filter and Base - Remove and Install
446D Backhoe Loader Power Train Rear Axle - Remove
446D Backhoe Loader Engine Supplement Refrigerant Condenser - Remove and Install
CB-334E and CB-335E Vibratory Compactors Machine Systems Drive Shaft - Remove and Install
446D Backhoe Loader Power Train Rear Axle - Install
CB-334E and CB-335E Vibratory Compactors Engine Supplement Engine - Install
988H Wheel Loader Machine Systems Evaporator Coil and Heater Coil - Install
CP-323C and CS-323C Paving Compactors Machine Systems Wheel and Tire - Remove and Install
R2900G Load Haul Dump Machine Systems Accumulator Charging Valve (Brake) - Remove
R2900G Load Haul Dump Machine Systems Accumulator Charging Valve (Brake) - Install
2004/06/21 Special Instruction, REHS2149, "Explanation of Common Event Codes and Transmission Shift Matrix" is now Available {4800, 4808}
824H Wheel Dozer, 825H Soil Compactor and 826H Landfill Compactor Machine Systems Front Frame from Rear Frame - Separate