0030-13 PTO Throttle out of calibration (29)
产生此代码的情况:
发动机控制模块 (ECM) 检测到以下情况:
- PTO 油门信号占空比低于 5% 或高于 95% 超过 2 秒。
- PTO 配置被设为 "远程油门"。
- ECM 至少已通电三秒钟。
系统响应:
ECM 在检测到故障后会使发动机恢复到低怠速。 在卡特彼勒电子技师 (ET) 中,在 "油门位置"的旁边将会显示 "诊断"。
该诊断代码为激活状态时,发动机会一直保持在低怠速下。
注: 远程油门踏板位置传感器无法标定。
测试步骤 1. 进行以下的诊断步骤: 远程 PTO 油门位置传感器电路 - 测试
结果:
- 正常 - 停止
Caterpillar Information System:
3126B and 3126E On-highway Engines 0030-08 PTO Throttle signal invalid (29)
C9 Marine Auxiliary and Generator Set Engines Engine Oil Sample - Obtain
3406E, C-10, C-12, C-15, C-16 and C-18 On-highway Engines 0231-02 J1939 Data Incorrect (58)
C7 and C9 On-Highway Engines 0111-14 Low Coolant Level Warning
3056E Industrial Engine Crankshaft Gear - Remove and Install
C18 Generator set and C18 Marine Engines Rocker Arm and Shaft - Remove
C11, C13 and C15 On-highway Engines Engine Speed/Timing Sensor Circuit - Test
3056E Industrial Engine Idler Gear - Remove and Install
G3304B and G3306B Engines Engine Oil Filter Base
3056E Industrial Engine Camshaft Gear - Remove and Install
3126B Marine Engines E096 High Fuel Pressure
C11, C13 and C15 On-highway Engines Cooling Fan Is Always ON
UPS 250 and UPS 300 Uninterruptible Power Supplies Bearing Retainer - Remove and Install
C9 Marine Auxiliary and Generator Set Engines Zinc Rods - Inspect/Replace
UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Bearing Retainer - Remove and Install
C9 Marine Auxiliary and Generator Set Engines Fuel System Secondary Filter - Replace
C9 Marine Auxiliary and Generator Set Engines Heat Exchanger - Inspect
C7 and C9 On-Highway Engines Transmission (AT/MT/HT) Relay Circuit - Test
C18 Generator set and C18 Marine Engines Vibration Damper and Pulley - Remove and Install
3054E Industrial Engine Fan Drive - Remove and Install
3056E Industrial Engine Fuel Injection Pump - Remove
3056E Industrial Engine Fuel Injection Pump - Install
3406E, C12, C15 and C18 Marine Engines Engine Speed/Timing Sensor - Calibrate
3126B and 3126E On-highway Engines PTO Switch ON Lamp Circuit - Test