Inlet Manifold Pressure - Test
通过比较进气歧管的压力与技术营销信息(TMI)中给出的信息,即可检查发动机的效率。 应在发动机功率下降,但是发动机又没有切实的故障迹象时采用本测试。
TMI 中列出了进气歧管的正确压力。 这一信息是在下述工况下拟定的。
- 干式大气压力为 96 kPa (28.8 in Hg)
- 外部气温为 25
°C (77 °F)
- 燃油等级为 35 API
这些条件的任何变化都可能影响进气歧管的压力。 外部空气的温度可能会高于以上给出的数值,而大气压力可能会低于以上给出的数值。 这种情况会导致进气歧管压力的测量值低于技术销售信息资料(TMI)中的压力。 外部空气如果气温低于,大气压力高于以上给出的数值的话会导致进气歧管压力测量值高于技术销售信息资料(TMI)中的压力。
燃油密度差异也会使马力(失速速度)和增压压力发生变化。 如果燃油等级高于API比重等级35,进气歧管的压力可能会低于技术销售信息资料(TMI)中给出的压力。 如果燃油等级低于 35 API,进气歧管的压力可能会高于技术销售信息资料(TMI)中给出的压力。
注: 确保检查压力时进气和排气不受阻。
注: Caterpillar 电子技师(ET)可被用来检查进气歧管压力。
Show/hide table
所需工具     | ||
---|---|---|
零件号     | 零件描述     | 数量     |
1U-5470 或者 198-4240     |
发动机压力表总成 或者 数字压力指示器总成     |
1     |
Show/hide table
图 1 | g00293196 |
1U-5470 发动机压力表总成 |
有关使用 1U-5470 发动机压力表总成 所需的说明,请参阅专门说明书, SEHS8907, "使用 1U-5470 发动机压力表总成 "。 有关使用 198-4240 数字压力指示器总成 所需的说明,请参阅操作手册, NEHS0818, " 198-4240 数字压力指示器总成 的使用"。
Show/hide table
图 2 | g01134338 |
压力测试位置 (1) 旋塞 |
使用下述程序测量进气歧管压力:
- 将管塞 (1) 从进气口盖上拆下。
- 在进气口盖的测试位置上连接 1U-5470 发动机压力表总成 。
注: 需要 T 形管接头或某些其他管路部件才能将增压压力传感器连接到测试位置。
- 记录数值。
- 比较步骤 3 中记录的数值与 TMI 中给出的压力值。
Caterpillar Information System:
3056E Industrial Engine Crankcase Breather - Remove and Install
C9 Urban Transit Bus Engine Engine Wiring Harness Diagram
2002/12/09 Double Lip Wiper Seals Must Be Installed Properly {7562}
C11, C13, and C15 On-highway Engines Safety Messages
C7 Petroleum Engines Engine Oil Pressure - Test
C7 and C9 On-Highway Engines Warning Lamp Circuit - Test
Installation and Operation of the Cat QuickEvacTM System{0707, 1325} Installation and Operation of the Cat QuickEvacTM System{0707, 1325}
C11, C13 and C15 On-highway Engines Powertrain Data Link Circuit - Test
C11 and C13 On-Highway Engines Engine Design
C15 Engine Engine Valve Lash - Inspect/Adjust
C7 and C9 On-Highway Engines Cruise Control Parameters
3056E Industrial Engine Engine Oil Pump - Install
G3406 and G3412 Generator Set Engines Engine Monitoring System - Electronic Ignition System (EIS)
G3406 and G3412 Generator Set Engines Ignition System - Electronic Ignition System (EIS)
G3406 and G3412 Generator Set Engines Gas Pressure Regulator
3126B Marine Engines E030 High Transmission Oil Temperature Warning
3126B Marine Engines E113 High Transmission Oil Pressure
C13 Engine for Combat and Tactical Vehicles Fuel System
C9 Urban Transit Bus Engine Warning Lamp Circuit - Test
C11, C13 and C15 On-highway Engines Customer Specified Parameters
C11, C13 and C15 On-highway Engines Data Link Parameters
3612 and 3616 Engines Engine Support
C7 Petroleum Engines Turbocharger - Inspect
3056E Industrial Engine Cylinder Head - Remove