MID 036 - CID 0544 - FMI 08 Engine Cooling Fan Speed signal abnormal
Conditions Which Generate This Code:
The Electronic Control Module (ECM) has been powered for three seconds. The engine rpm is equal to or greater than the low idle rpm. The engine rpm is less than 2400 rpm for one minute. The fan speed is 0 rpm or the fan speed is greater than 2000 rpm for two seconds.
System Response:
The code is logged.
Test Step 1. Perform the following test: Engine Fan Control Solenoid
Results:
- OK - Stop.
- REPAIRED, OK - Stop.
Caterpillar Information System:
AP-1000D, AP-1055D, AP-655C, BG-2255C, BG-2455D and BG-260D Asphalt Pavers Temperature Sender
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0526 - FMI 11 Wastegate Valve open/short
AP-1000D, AP-1055D, AP-655C, BG-2255C, BG-2455D and BG-260D Asphalt Pavers Fuel Level Sender
C4.4 (Mech) Industrial Engine Lubrication System
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0291 - FMI 11 Engine Cooling Fan Solenoid open/short
2003/01/06 New Flash Software Is Now Used {7620}
C4.4 (Mech) Industrial Engine Cooling System
3524B Engine for Caterpillar Built Machines Flywheel Housing - Install
574B Forwarder Power Train Differential
D5N Track-Type Tractor Transmission System Oil Sample - Obtain
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0286 - FMI 06 EMS Oil Lamp short to +batt
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0286 - FMI 05 EMS Oil Lamp open/short to ground
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0829 - FMI 03 Rear Aftercool Temperature open/short to +batt
14H and 16H Motor Graders Power Train Transmission Control Valve
2002/11/04 Connecting Rods with Dual Bearing Tab Slots are OK to Use {1218}
2002/11/11 A New Transmission Pressure Switch is now Used {3016, 3154}
TH210 and TH215 Telehandlers Power Train Front Axle (Fixed) - Remove
TH340B, TH350B, TH355B, TH360B, TH460B and TH560B Telehandlers Window Wiper and Wiper Motor (Front) - Remove and Install
14H Motor Grader Additional Messages
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0829 - FMI 04 Rear Aftercool Temperature short to ground
14H Motor Grader Operator Controls
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0830 - FMI 03 Front Brake Oil Temperature open/short to +batt
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0830 - FMI 04 Front Brake Oil Temperature short to ground
R2900 Load Haul Dump Steering Cylinder Bearings - Lubricate