Fault Codes
Show/hide table
| Fault Code List | |
|---|---|
| Three-Point Hitch Function And Electronic Draft Function | |
| F001 | Transient Reset |
| F002 | Channel Lockup - CCM Internal Error |
| F003 | True Ground Speed Greater Than Transmission Speed |
| F004 | Transmission Speed Greater Than Maximum Speed |
| F006 | Slip Limit Override Potentiometer - Failed Low |
| F007 | Slip Limit Override Potentiometer - Failed High |
| F008 (1) | Raise/Work Switch - Failed High |
| F009 | Fender Three-Point Switches - Both Activated |
| F010 | Height Limit Potentiometer - Failed Low |
| F011 | Height Limit Potentiometer - Failed High |
| F012 | Drop Rate Potentiometer - Failed Low |
| F013 | Drop Rate Potentiometer - Failed High |
| F014 | Right Draft Pin Sensor - Failed Low |
| F015 | Right Draft Pin Sensor - Failed High |
| F016 | Left Draft Pin Sensor - Failed Low |
| F017 | Left Draft Pin Sensor - Failed High |
| F018 | Both Draft Pin Sensors - Disconnected or Failed |
| F019 | CCM Sensor 8 Volt Supply - Failed Low |
| F020 | CCM Sensor 8 Volt Supply - Failed High |
| F021 | Sensitivity Potentiometer - Failed Low |
| F022 | Sensitivity Potentiometer - Failed High |
| F024 | Perform Hitch Calibration |
| F025 | Three-Point Lever Position Potentiometer - Failed Low |
| F026 | Three-Point Lever Position Potentiometer - Failed High |
| F027 | Rockshaft Potentiometer - Failed Low |
| F028 | Rockshaft Potentiometer - Failed High |
| F029 | Both Three-Point Solenoid Valves - Low Current |
| F030 | All Three-Point Potentiometers - Failed High |
| F057 | Both Three-Point Solenoid Valves - On without Command |
| F058 | Draft Pin Sensor and Rockshaft Potentiometer - Failed High |
| F059 | Raise/Work Switch - Failed Low |
| F063 | Three-Point Lower Solenoid - Low Current |
| F064 | Three-Point Raise Solenoid - Low Current |
| F098 | Rockshaft Potentiometer - Signal Noise |
| F099 | Three-Point Potentiometers - Signal Noise |
| Right Hand Controls (RHC) | |
| F100 | RHC Sensor 5 Volt Supply - Failed Low |
| F101 | RHC Sensor 5 Volt Supply - Failed High |
| F102 | Upshift Switch - Failed High |
| F103 | Upshift Switch - Failed Low |
| F104 | Downshift Switch - Failed High |
| F105 | Downshift Switch - Failed Low |
| F106 | Reverse Shift Switch - Failed High |
| F107 | Reverse Shift Switch - Failed Low |
| F108 | Forward Shift Switch - Failed High |
| F109 | Forward Shift Switch - Failed Low |
| Electronic Monitoring Center (EMC) | |
| F200 | EMC 5 Volt Supply - Failed Low |
| F201 | EMC Output Circuit - Short |
| F202 | CAN Error Between EMC and RHC |
| F203 | CAN Error Between EMC and Draft Control Circuits of CCM |
| F204 | CAN Error Between EMC and Transmission Control Circuits of CCM |
| F205 | Features Disagree |
| F207 | Brakes Engaged While Moving |
| F208 | EMC Sensor 5 Volt Supply - Failed High |
| F209 | Air Inlet Heater Switch - Stuck On |
| Transmission Control Function | |
| F300 | Transmission Solenoid 1 - High Current |
| F301 | Transmission Solenoid 2 - High Current |
| F302 | Transmission Solenoid 3 - High Current |
| F303 | Transmission Solenoid A - High Current |
| F304 | Transmission Solenoid B - High Current |
| F305 | Transmission Solenoid C - High Current |
| F306 | Transmission Solenoid F1 - High Current |
| F307 | Transmission Solenoid F2 - High Current |
| F308 | Transmission Solenoid MC1 - High Current |
| F309 | Transmission Solenoid MC2 - High Current |
| F310 | Transmission Solenoid REV - High Current |
| F311 | Transmission Solenoid CREEPER - High Current |
| F312 | Air Inlet Heater Relay - High Current |
| F313 | Fuel Hold-In Solenoid - High Current |
| F314 | PTO Solenoid - High Current |
| F315 | Steering Reverse Solenoid - High Current |
| F316 | Fuel Pull-In Relay - High Current |
| F317 | Connector C003 - Open |
| F318 | Connector C002 - Open |
| F319 | Connector C001 - Open |
| F320 | Transmission Solenoid 1 - Low Current |
| F321 | Transmission Solenoid 2 - Low Current |
| F322 | Transmission Solenoid 3 - Low Current |
| F323 | Transmission Solenoid A - Low Current |
| F324 | Transmission Solenoid B - Low Current |
| F325 | Transmission Solenoid C - Low Current |
| F326 | Transmission Solenoid F1 - Low Current |
| F327 | Transmission Solenoid F2 - Low Current |
| F328 | Transmission Solenoid MC1 - Low Current |
| F329 | Transmission Solenoid MC2 - Low Current |
| F330 | Transmission Solenoid REV - Low Current |
| F331 | Transmission Solenoid CREEPER - Low Current |
| F332 | Air Inlet Heater Relay - Low Current |
| F333 | Fuel Hold-In Solenoid - Low Current |
| F334 | PTO Solenoid - Low Current |
| F335 | Steering Reverse Solenoid - Low Current |
| F336 | Fuel Pull-In Relay - Low Current |
| F338 | CCM Sensor 5 Volt Supply - Failed Low |
| F339 | CCM Sensor 5 Volt Supply - Failed High |
| F340 | Transmission Speed Sensor - Failed High |
| F341 | Transmission Speed Sensor - Failed Low |
| F342 | Engine RPM Sensor - Failed High |
| F343 | Engine RPM Sensor - Failed Low |
| F344 | Engine RPM Sensor - Failed |
| F345 | Transmission Speed Sensor - Failed |
| F346 | Inching Pedal Potentiometer - Failed Low |
| F347 | Inching Pedal Potentiometer - Failed High |
| F348 | Inching Pedal Potentiometer - Low Calibration Error |
| F349 | Inching Pedal Potentiometer - High Calibration Error |
| F350 | Clutch Switch and Inching Pedal Potentiometer Disagree when Pedal Depressed |
| F351 | Clutch Switch and Inching Pedal Potentiometer Disagree when Pedal Released |
| F360 | Transmission F1 - Calibration Error |
| F361 | Transmission F2 - Calibration Error |
| F362 | Transmission REV - Calibration Error |
| F363 | Shuttle Constant - CCM Internal Error |
| F365 | F1/F2 Shift Constant - CCM Internal Error |
| F366 | F2/F1 Shift Constant - CCM Internal Error |
| F377 | Transmission Configuration Byte 1 - CCM Internal Error |
| F378 | Transmission Configuration Byte 2 - CCM Internal Error |
| F379 | Transmission Configuration Byte 3 - CCM Internal Error |
| F380 | Prototype Hardware Revision - CCM Internal Error |
| F381 | Production Hardware Revision - CCM Internal Error |
| F382 | Upshift Constant - CCM Internal Error |
| F383 | Downshift Constant - CCM Internal Error |
| F386 | Transmission Oil Temperature - Too High (Shutdown) |
| F387 | Transmission Oil Pressure - Too Low (Shutdown) |
| F388 | Transmission Oil Pressure Switch - Failed Low |
| F389 | Transmission Oil Temperature Sensor - Failed Low |
| F390 | Transmission Oil Temperature Sensor - Failed High |
| F392 | Transmission Filter - Bypass Occurring |
| F393 | Directional Input and Gearshift Switch - Disagree |
| F394 | Steering/Implement Filter - Bypass Occurring (Shutdown) |
| F395 | Track tension status |
| F399 | Transient Reset of Modules |
| Engine Control Function | |
| F400 | Coolant Temperature - Too High (Shutdown) |
| F401 | Engine Oil Pressure - Too Low (Shutdown) |
| F403 | Aftercooler Temperature - Too High |
| F404 | Fuel Level Sensor - Failed Low |
| F405 | Fuel Level Sensor - Failed High |
| F406 | Coolant Temperature Sensor - Failed Low |
| F407 | Coolant Temperature Sensor - Failed High |
| F408 | Engine Oil Pressure Sensor - Failed Low |
| F411 | Aftercooler Temperature Sensor - Failed Low |
| F412 | Aftercooler Temperature Sensor - Failed High |
| F413 | Radar Sense Input - Not Detected |
| F414 | Radar Signal Input - Not Detected |
| F415 | Coolant Level Sensor - Failed Low |
| F416 | Coolant Level Sensor - Failed High |
| F417 | Air Filter Status |
| F418 | Coolant Level Status |
| F419 | Alternator - Not Charging |
| F420 | Alternator - Overcharging |
| F421 | Battery Voltage at EMC - Low |
| F422 | Connector C008 - Open |
Show/hide table
| ( 1 ) | This fault code is available on software that was released earlier than etc0540.bin, edc0620.bin, emc0670.bin, and rhc0320.bin. |
Caterpillar Information System:
3524B and C175 Engines for Off-Highway Truck/Tractors Accessory Drive
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Troubleshooting
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines ETR Junction Box-Switchgear Not Required (OP,WT,OS)
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks MID 036 - CID 0248 - FMI 09 Cat Data Link not communicating
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Electrical Test Procedures
24H Motor Grader Braking System Towing
834G Wheel Dozer and 836G Landfill Compactor Power Train General Information
24H Motor Grader Braking System Filters and Screens
Generator Service Literature Index{4450} Generator Service Literature Index{4450}
D350E Series II and D400E Series II Articulated Trucks Steering, Suspension, and Body Hoist Hydraulic Systems Accumulator (Suspension) - Test and Charge
24H Motor Grader Braking System Pressure Switch
416C, 426C, 428C, 436C and 438C Backhoe Loaders Hydraulic and Steering System Steering Cylinder (2WD)
789C Off-Highway Truck Engine Supplement Cowling (Radiator) - Install
D350E Series II and D400E Series II Articulated Trucks Steering, Suspension, and Body Hoist Hydraulic Systems Tailgate Cylinder - Test
797 Off-Highway Truck Engine Supplement Muffler - Remove
Weld Repair Procedure for Field Retrofit of Large Off-Highway Truck Frame Superstructure {7050, 7253} Weld Repair Procedure for Field Retrofit of Large Off-Highway Truck Frame Superstructure {7050, 7253}
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines ETR Junction Box-Switchgear Not Required (OP,WT)
797 Off-Highway Truck Steering System Relief Valve (Steering) - Test and Adjust - Backup Relief Valve
554 Forwarder and 574 Forwarder Lubricant Viscosities
Challenger 65C, Challenger 65D, Challenger 65E, Challenger 70C, Challenger 75C, Challenger 75D, Challenger 75E, Challenger 85C, Challenger 85D, Challenger 85E and Challenger 95E Agricultural Tractors Machine Performance Panel Speed Sensor (Engine)
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Steering Control - Remove
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Steering Control - Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Hitch (Lift Arm) - Remove and Install
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Machine Systems Hitch (Lift Link) - Remove and Install