Oil Filter (Transmission) - Replace
滤清器筒
Show/hide table
CX31机油滤清器     | ||
---|---|---|
滤清器类型     | 滤芯规格     | 零件号     |
空压机组件     | 236 x 102 mm(9.3 x 4.0 in)     | 249-2329     |
旋装式     | 295 x 116 mm(11.6 x 4.6 in)     | 126-1817     |
- 拆下排放螺塞 (3) 。 将机油排放到适当的容器中。 更换排放螺塞 (3) 。 拧紧扭矩至 18 ± 3.5 N·m (13 ± 3 lb ft)。
Show/hide table
热油和热的部件可能会导致人员受伤。 不要让热的油和部件接触皮肤。 |
Show/hide table
注意 |
---|
在检验、保养、测试、调整及维修发动机时,请小心确保盛接流出的液体。 在打开或拆解任何储有液体的部件之前,要准备好合适的容器收集液体。 有关适合收集和盛接卡特彼勒产品上的液体的工具和供应品,请参阅专门出版物, NENG2500, "卡特彼勒代理商工具目录"。 按照本地法规和条例处置所有液体。 |
Show/hide table
图 1 | g01237675 |
(1) 滤清器底座 (2) 滤清器壳体 (3) 滤清器排放螺塞 |
- 拆下机油滤清器壳体 (2) 。 废弃壳体 (2) 内用过的机油滤清器滤芯。 拆下滤清器时将会排出剩余的机油。 将机油排放到适当的容器中。
- 检查壳体 (2) 上的油封。 如果油封损坏,用新的油封更换。
- 将新机油滤清器滤芯装入壳体 (2) 内。
- 将壳体 (2) 和新滤芯装入滤清器底座 (1) 内。 将壳体拧紧至 55 ± 5 N·m (41 ± 4 lb ft)。 不要使用气动扳手拧紧。
- 确保变速箱处于空档 。 起动发动机并在低怠速下运转。 检查有无泄漏并进行必要的修理。
- 当油温热且变速箱在空档位置时,观察油位 (4) 。 确保停车制动器已接合。
Show/hide table
图 2 | g01240908 |
(4) 加注管 |
- 关闭发动机。 如有需要,加注机油。
旋装式滤清器
Show/hide table
图 3 | g01237691 |
(1) 滤清器底座 (2) 机油滤清器 |
- 拆下机油滤清器 (2) 。 弃置用过的机油滤清器。 拆卸滤清器时机油将排出。 将机油排放到适当的容器中。
- 安装机油滤清器。 拧紧机油滤清器直到机油滤清器垫圈接触底座 (1) 。 按照在机油滤清器上的说明用手拧紧机油滤清器。 不要过分拧紧机油滤清器。 不要使用气动扳手拧紧。
- 确保变速箱处于空档。 起动发动机并在低怠速下运转。 检查有无泄漏并进行必要的修理。
- 当油温热和变速箱在空档位置时,观察油位。 确保停车制动器已接合。
- 关闭发动机。 如有需要,加注机油。
Caterpillar Information System:
CX31 On-Highway Transmission Magnetic Screen (Transmission) - Clean
CX31 On-Highway Transmission Capacities (Refill)
XQP150 Rental Generator Set Water Pump - Inspect
CX31 On-Highway Transmission Retarder Operation
Inspecting the Fuel System for the Aftertreatment Regeneration Device (ARD){107P, 1088, 1722} Inspecting the Fuel System for the Aftertreatment Regeneration Device (ARD){107P, 1088, 1722}
CX31 On-Highway Transmission Transmission Operation
G3500 A3 Engines Low Power/Poor or No Response to Throttle
C6.6 Engines for Caterpillar Built Machines Fuel Priming Pump - Remove and Install - Mechanical Priming Pump
3408C and 3412C Marine Engines Engine Oil Lines
C13 and C15 On-highway Engines Output Selection Parameters
C13 and C15 On-highway Engines Vehicle Speed Parameters
C13 and C15 On-highway Engines Vehicle Activity Report Parameters
CX31 On-Highway Transmission Reference Material
C32 Power Module Fuel System Primary Filter/Water Separator - Drain
Troubleshooting Fuel Injector Failures on Some C13 and C15 On-highway Engines{1290, 1408} Troubleshooting Fuel Injector Failures on Some C13 and C15 On-highway Engines{1290, 1408}
2007/07/16 High Copper Reported in Routine Engine Oil Samples {1308, 1318, 1348}
C13, C15, and C18 Tier 4 Final Engines Exhaust Manifold
12M Motor Grader Before Operation
C11 and C13 Engines and 14M and 16M Motor Graders Sensor Signal (Analog, Passive) - Test
C9 Petroleum Engines Engine Oil and Filter - Change
A Recommendation for Initial Parts Stock Quantities Will Now Be Included in Service Letters{1000, 7000, 7751, 7752} A Recommendation for Initial Parts Stock Quantities Will Now Be Included in Service Letters{1000, 7000, 7751, 7752}
Reusability of Drive Train Gears {3002, 3159, 3256, 4055} Reusability of Drive Train Gears {3002, 3159, 3256, 4055}
C11 and C13 Petroleum Engines Warranty Information
C3.3 Industrial Engine Engine Design